Abstract:The modification of cordierite honeycomb (CH) carrier is conducive to improve the catalytic activity of catalyst that applying in the treatment of real VOCs waste gas. A honeycombed calcium aluminum silicate hydrate (C–A–S–H) thin layer was self-assembled successfully by alkaline corrosion with supersaturated Ca(OH)2 and contacted robustly onto the CH surface (named as CHC) by chemical bond. CuMnCeOx/CHC catalyst was prepared and applied in microwave catalytic combustion of toluene to check the catalytic activity in this work. Compared with CuMnCeOx/CH catalyst, CuMnCeOx/CHC catalyst exhibited a higher catalytic capacity and the removal rate of toluene reached 99%, which was higher than 75% of CuMnCeOx/CH catalyst under same reaction conditions of toluene initial concentration 1000 mg m−3, air flow 0.12 m3 h−1 and bed temperature 200 °C. Based on SEM, BET, XRD, XPS, UV-Raman, H2-TPR and NH3-TPD characterizations, it showed clearly that honeycombed C–A–S–H thin layer made CuMnCeOx active particles with smaller size more uniformly embedded into the pores of itself to hinder effectively the agglomeration of active particles in reaction. The valence reversible conversion of Cu+/Cu2+, Mn2+/Mn3+/Mn4+ and Ce3+/Ce4+ and total valence increase of CuMnCeOx produced abundant oxygen vacancies on the catalyst surface and simultaneously improved the transformation of surface adsorbed oxygen (Oads) to lattice oxygen (Olatt). Toluene was oxidized completely by Oads and Olatt species onto the active sites and “hot spots” under microwave irradiation that following both L–H mechanism and MvK mechanism. The research work lays down a theoretical basis for the preparation of highly effective catalyst and further application in the treatment of industrial VOCs waste gas.Graphical Abstract

Preparation of CuOx-CeO2/GAC catalyst in microwave enhanced CWPO process and degradation of DMSO

Highly Efficient Degradation of Pharmaceutical Sludge by Catalytic Wet Oxidation Using CuO-CeO2/γ-Al2O3 As a Catalyst

Preparation of mesoporous Ce2O3/WO3 by microwave and its potocatalytic degradation for paper process effluent

Preparation and Properties of Cu-Ni Bimetallic Oxide Catalyst Supported on Activated Carbon for Microwave Assisted Catalytic Wet Hydrogen Peroxide Oxidation for Biologically Pretreated Coal Chemical Industry Wastewater Treatment.

Preparation and characterization of Fe2O3-CeO2-TiO2/gamma-Al2O3 catalyst for degradation dye wastewater.

CoFe2O4 with MoS2-xOy Nanosheets As a Co-catalyst for Enhanced Activation of Peroxydisulfate in Advanced Oxidation Processes

The Green Preparation of Mesoporous WO3/SiO2 and Its Application in Oxidative Desulfurization

Preparation, Characterization and Activity of CuMnCeOx/CHC Catalyst in Microwave Catalytic Combustion of Toluene

Catalytic wet air oxidation of high-strength organic coking wastewater

CuO-Co3O4@CeO2 As a Heterogeneous Catalyst for Efficient Degradation of 2,4-Dichlorophenoxyacetic Acid by Peroxymonosulfate.

A Novel CWPO/H2O2/VUV Synergistic Treatment for the Degradation of Unsymmetrical Dimethylhydrazine in Wastewater

Singlet oxygen-dominated non-radical oxidation pathway for 2,4-Dichlorophenol degradation over CeO2 coated carbon fibers

Enhanced Activity And Stability Of Copper Oxide/Gamma-Alumina Catalyst In Catalytic Wet-Air Oxidation: Critical Roles Of Cerium Incorporation

Singlet Oxygen Dominated Peroxymonosulfate Activation by CuO-CeO2 for Organic Pollutants Degradation: Performance and Mechanism.

Characteristics of CuO-MoO3-P2O5 Catalyst and Its Catalytic Wet Oxidation (CWO) of Dye Wastewater under Extremely Mild Conditions.

Efficient activation of peroxymonosulfate by Co-doped mesoporous CeO2 nanorods as a heterogeneous catalyst for phenol oxidation

Wet air oxidation of pretreatment of pharmaceutical wastewater by Cu 2+ and [P xW mO y] q- co-catalyst system

Preparation and activity of Fe2O3-CeO2/γ-Al2O3 catalyst for catalytic wet peroxide oxidation of dye wastewater

Facile synthesis of mesoporous Co3O4 with excellent performance for activation of PMS

Preparation and Catalytic Properties of Cu2O–CoO/Al2O3 Composite Coating Prepared on Aluminum Plate by Microarc Oxidation

Three-dimensional ordered macroporous ceria–lanthanum cobaltate composite as efficient catalyst to activate peroxymonosulfate for N,N-dimethylformamide degradation