Abstract:In this paper, eight solid-state diffusion couples in fcc ternary Cu-Ni-Al alloys at 1073, 1173 and 1273 K were prepared, and the corresponding composition profiles were measured with an electron probe microanalyzer (EPMA) technique. Based on the measured composition profiles and HitDIC software, a set of reliable atomic mobility descriptions in the fcc Cu-Ni-Al system were directly established, from which the composition- and temperature-dependent interdiffusion coefficient matrices were evaluated. Then, the three-dimensional (3D) main interdiffusivity surfaces for fcc Cu-Ni-Al systems were constructed. The diffusion rate of Al is faster than that of Ni. Both the main interdiffusivities of Al and Ni increase with the increase of Al concentration but decrease with Ni concentration. The reliability of the evaluated interdiffusivities was first validated by reproducing the measured composition profiles and interdiffusion fluxes. After that, the interdiffusivities and corresponding uncertainties at intersection points of diffusion couples were evaluated by using the Matano–Kirkaldy method combined with distribution functions. Especially all the interdiffusion coefficients estimated from the present mobility parameters are within the bounds of the uncertainties, which further quantitatively verified the reliability of the present mobility descriptions. The accuracy of the as-determined mobility is further highlighted via combining with the reported thermodynamic descriptions, which enables an accurate prediction of the volume of Ni3Al precipitates in the Cu-Ni-Al alloy during artificial aging. The present work indicates that with the accurate thermodynamic as well as boundary mobility descriptions, reliable ternary mobility descriptions can be achieved by combining the diffusion couple experiments with the HitDIC modeling.

Atomic Mobilities and Interdiffusivities in Ni-rich Fcc Ni-Co-Cr and Ni-Al-Co-Cr Systems Evaluated Using Composition Profiles and HitDIC

Assessment of Mobilities of the B2 Phase in the Nickel-Chromium-Aluminum System

Interdiffusion and Atomic Mobility Studies in Ni-Rich Fcc Ni-Co-Al Alloys

Diffusion behavior of fcc and L12 Ni–Al–Cr alloys

Interdiffusion and Atomic Mobilities in Ni-rich fcc Ni-Cr-W Alloys

Diffusion Behavior Of Fcc And L1(2) Ni-Al-Cr Alloys

High-Throughput Determination of Composition-Dependent Interdiffusivity Matrices and Atomic Mobilities in Fcc Cu-Ni-Al Alloys by Combining Diffusion Couple Experiments with HitDIC Modeling

Interdiffusion and Atomic Mobility Studies in Ni-rich Fcc Ni−Al−Mn Alloys

Experimental Investigations on the Quinary Interdiffusivities in Diffusion Couples of NiAlCoCr Alloy/cocrfeni High-Entropy Alloys

Interdiffusion and Atomic Mobilities in Ni-rich fcc Ni-Nb-Ti Alloys

High-Throughput Measurement of the Composition-Dependent Interdiffusivity Matrices of Fcc Cu-Al-Co-Cr-Fe-Ni Systems

Interdiffusion and Atomic Mobilities in Fcc Ni-Ti-Mo Alloys

Experimental Investigation of Diffusion Behaviors in Γ and Γ’ Ni–Al–Co Alloys

Interdiffusion and Atomic Mobilities Studies in Ni-Rich Fcc Ni-Ti-V Alloys

Interdiffusion Behaviors Between NiCrFe Alloy and Low-/Medium-/high-entropy Alloys

Diffusion coefficients and atomic mobilities in fcc Ni-Cu-Mo alloys: Experiment and modeling

High-throughput Determination of Accurate Interdiffusivity Matrices and Atomic Mobilities in Fcc Co-Mn-X (X = Fe, Ni) Alloys

Atomic Mobilities and Diffusivities in the Fcc, L12and B2 Phases of the Ni-Al System

Composition-dependent Interdiffusivity Matrices in Face Centered Cubic Ni–Al–X (X = Rh and W) Alloys at 1423, 1473 and 1523 K: A High-Throughput Experimental Measurement

Interdiffusion and Atomic Mobilities in Co-rich Fcc Co-Cr-V Alloys

Interdiffusivities and Atomic Mobilities in fcc Ni-Cu-Si Alloys