Abstract:A novel gas-gas ejector enhanced autocascade refrigeration cycle is proposed in this paper. The novel cycle uses an additional gas-gas ejector and a phase separator to accomplish a secondary composition separation for the zeotropic mixture used in the cycle. This proposed cycle can lift the evaporating pressure for a specific evaporating pressure and further improve the cycle performance. The performance comparisons between the novel cycle and a basic autocascade refrigeration cycle using the zeotropic mixtures of R23/R134a are conducted by theoretical method. In the evaporator inlet temperature range of -60°C to -40°C, the coefficient of performance (COP) and volumetric cooling capacity of the novel cycle can be improved by up to an average of 25.9% and 32.7% compared to that of the basic cycle, respectively. The effect of some key parameters on the performance of the novel cycle is further investigated. As the intermediate pressure of the novel cycle decreases in a certain range, the entrainment ratio and pressure lift ratio of the ejector increase and it further leads to the performance improvement of the novel cycle. In a given vapor quality range, the COP of the basic cycle show a monotonic increase tendency with the vapor quality at the condenser outlet, but the novel cycle has an optimal vapor quality to obtain the maximum COP. The simulation results shows that the novel cycle yields an improvement of 40.1-21.4% in the COP over the basic cycle as the vapor quality varies from 0.3 to 0.5. Besides, there exist optimal mixture compositions for the two cycles to obtain the optimum performance. The maximum COP of the two cycles can be obtained under the considered condition when the R134a mass fraction of the zeotropic mixture R23/R134a at the compressor inlet is fixed at about 0.6.

Thermodynamic Analyses of a Flash Separation Ejector Refrigeration Cycle with Zeotropic Mixture for Cooling Applications

Performance Evaluation of an Ejector Subcooling Refrigeration Cycle with Zeotropic Mixture R290/R170 for Low-Temperature Freezer Applications

Performance Study of an Enhanced Ejector Refrigeration Cycle with Flash Tank Economizer for Low-Grade Heat Utilization

Energy and exergy analysis of zeotropic mixture R290/R600a vapor-compression refrigeration cycle with separation condensation

Theoretical investigation on an ejector–expansion refrigeration cycle using zeotropic mixture R290/R600a for applications in domestic refrigerator/freezers

Theoretical Investigation on the Performance of a Modified Refrigeration Cycle Using Binary Zeotropic Hydrocarbon Mixture R170/R290

Theoretical Study of A Transcritical Ejector Refrigeration Cycle with Refrigerant R143a

Performance Analysis of an Advanced Ejector-Expansion Autocascade Refrigeration Cycle

Performance Analysis of a Modified Zeotropic Mixture (R290/R600) Refrigeration Cycle with Internal Subcooler for Freezer Applications

Theoretical Study on a Modified Single‐stage Autocascade Refrigeration Cycle with Auxiliary Phase Separator

Performance Evaluation of a Modified Refrigeration Cycle with Parallel Compression for Refrigerator-Freezer Applications

Energy and Exergy Analysis of a Novel Two-Stage Ejector Refrigeration Cycle Using Binary Zeotropic Mixtures{fr}analyse De L’énergie Et De L'exergie D'un Nouveau Cycle De Réfrigération À Éjecteur À Deux Étages Utilisant Des Mélanges Zéotropes Binaires

Performance evaluation on an internal auto-cascade refrigeration cycle with mixture refrigerant R290/R600a

Performance Analysis of a Modified Autocascade Refrigeration Cycle with an Additional Evaporating Subcooler

Energy and exergy analysis of a new ejector enhanced auto-cascade refrigeration cycle

Theoretical Analysis of a Double Ejector-Expansion Autocascade Refrigeration Cycle Using Hydrocarbon Mixture R290/R170

Thermodynamic Analysis on a Modified Ejector Expansion Refrigeration Cycle with Zeotropic Mixture (r290/r600a) for Freezers

Thermodynamic Analyses of Ejector Refrigeration Cycle with Zeotropic Mixture

Theoretical Investigation on the Performance of an Ejector Enhanced Refrigeration Cycle Using Hydrocarbon Mixture R290/R600a

Thermodynamic Analysis on A Novel Gas-gas Ejector Enhanced Autocascade Refrigeration Cycle

Performance Analysis of an Ejector Enhanced Refrigeration Cycle with R290/R600a for Application in Domestic Refrigerator/freezers