Abstract:Electric impedance properties of biological tissue closely relate with their tissue structure. A few published investigations have shown that electric impedance has a rapid detection capability to meat quality. To explore the impedance detection ability for frozen-thawed meat, electric impedance magnitude and phase properties of unfrozen and frozen-thawed chicken breasts subjected to different thawing times were studied. The maximum freezing-thawing circle was three times. Sixteen different frequencies from 50 Hz to 200 kHz and quality parameters like thawing loss, cooking loss, pH value, and TBARS (Thiobarbituric acid reactive substances) of 20 samples of each group were investigated. The impedance of the samples was measured by an LCR electronic bridge at the voltage of 3 V. Copper needle electrodes with a length up to 15 mm and a distance of 15 mm between two electrodes were used. The temperature of the meat was kept within 0-4℃during the measurement. The location of each test was the same and measurement time was 1-2 sec at every frequency. The experimental results showed that changes in the tissue structure caused by freezing and thawing could be reflected by the impedance magnitude and phase. The impedance magnitude of both fresh and frozen-thawed meat would decrease as the frequencies increased and the impedance magnitude of fresh meat was significantly higher (P<0.01) than frozen-thawed meat in the low-frequency range, while the opposite trend was found in the high-frequency range. Those changing trends of impedance are indicators for capacitance characteristics of cell remembrance. Biological tissues are composed of cells that are surrounded by extracellular liquid. The main current flows through the extracellular fluid and the cells are bypassed when low-frequency current is applied to the tissue. The cell membrane acts as an insulator at low frequencies. With the current frequency increases, a part of the current will flow through intracellular fluid through the cell membrane. So, low-frequency impedance of biological tissue is larger than high-frequency impedance. The impedance phase angle of both fresh and frozen-thawed meat would increase as the frequencies increase. Compared with frozen-thawed meat, fresh meat had a higher (P<0.05) impedance phase angle in the low-frequency range but a lower (P<0.05) value in the high-frequency range. So, the significant difference (P<0.05) of high-frequency phase angle and low-frequency impedance magnitude between fresh and frozen-thawed meat would be an ideal index to distinguish those two kinds of meat. After freezing-thawing cycles, low-frequency impedance magnitude would decrease significantly (P<0.05), but the difference between two and three times freezing-thawing cycle was not significant (P>0.05). High-frequency phase angle would increase (P<0.05) which is different with normal frozen processing groups, especially at levels higher than 50 kHz. This impedance phase property of meat with more than one freezing-thawing cycle gives a clear distinction between them and meat with one freezing-thawing cycle. These changes of impedance properties demonstrate that freezing-thawing cycles have a remarkable influence on the structure of cell membrane and lead to a decline of cell membrane capacitance. From the quality aspect, the increasing of freezing-thawing cycles lead to inevitable decline in meat quality. More thawing loss, cooking loss and higher TBARS value are found after freezing-thawing cycles. The precise calculation of the quality by impedance measurement could not be obtained for no accordant significant correlation (P>0.05) was found between impedance properties and quality parameters in different groups. Radial Basis Function (RBF) Neural Networks that are built up based on impedance magnitude and phase angle of specific frequencies from 50 Hz to 200 kHz (Total 12 frequencies) could give a solution to estimate the freezing-thawing cycles of meat without complex mathematics modeling, and the prediction accuracy satisfies the requirement. Accuracy of the testing samples of fresh chicken meat was up to 100 percent, one time freezing-thawing cycle samples also had a high degree of distinction from two and three times. These results reflect that electrical impedance measurement is a simple innocuous tool for frozen meat characterization. For improving the measurement accuracy, a dadatabase with a big enough data volume needs to be built in future work.

Classification of chicken breasts with different freezing-thawing cycles by impedance properties and artificial neural networks

Classification of Chicken Muscle with Different Freeze–thaw Cycles Using Impedance and Physicochemical Properties

The Use of the Impedance Measurements to Distinguish Between Fresh and Frozen–thawed Chicken Breast Muscle

Analysis of the Suitable Thawing Endpoint of the Frozen Chicken Breast Using Video Recording Analysis, Shear Force, and Bioelectrical Impedance Measurement.

Effect of Freezing on Electrical Properties and Quality of Thawed Chicken Breast Meat

Research on the Effect of Different Electrode Structures on the Response Effect of Chilled Chicken Breast Impedance

Bio-impedance measurements for meat quality determination of pork loins under repeated freeze-thaw treatments

Multi-Frequency Bioimpedance Combined with Machine Learning for Frozen-Thawed Quality Evaluation of Atlantic Salmon

Rapid Differentiation of Unfrozen and Frozen-Thawed Tuna with Non-Destructive Methods and Classification Models: Bioelectrical Impedance Analysis (BIA), Near-Infrared Spectroscopy (NIR) and Time Domain Reflectometry (TDR)

Effects of Radio Frequency Thawing on the Quality Characteristics of Frozen Mutton

Effects of Different Isochoric Freeze-Thaw Cycles on the Physicochemical Quality Attributes of Chicken Breast Meat

Application of Nondestructive and Low‐Cost Impedance Technology to Determine the Effect of Curing Degree on Meat Quality

Fabrication of sensor array based on quartz crystal microbalance and its detection for egg shelf life

Effects of Ultrasound-Assisted Immersion Freezing on the Muscle Quality and Physicochemical Properties of Chicken Breast

Effects of Different Thawing Methods on the Quality of Chicken Breast

Thermal Characterization and Ice Crystal Analysis in Pressure Shift Freezing of Different Muscle (shrimp and Porcine Liver) Versus Conventional Freezing Method

Effects of Different Freezing and Thawing Processes on Chicken Quality

Using electrical impedance detection to evaluate the viability of biomaterials subject to freezing or thermal injury

Rapid detection of frozen pork quality without thawing by Vis-NIR hyperspectral imaging technique.

Effect of Repeated Freezing and Thawing Cycles on Quality of Chicken

Discrimination among Fresh, Frozen-Stored and Frozen-Thawed Beef Cuts by Hyperspectral Imaging