Abstract:With the implementation of China’s Green Fence Policy and the following National Sword Policy, there is a need to divert previously accepted waste materials away from the landfill. Mixed plastic and paper wastes that are too contaminated to be economically recycled can be used for conversion into fuels and products. The effect of common contaminants present in waste streams must be determined to make municipal solid waste (MSW) a viable alternative to agricultural feedstocks for conversion. In this study, MSW was sourced from a dual stream materials recovery facility (MRF) in Emmet County, Michigan and characterized via mass balance. The most common contaminants in mixed paper and plastic were quantified and targeted for decontamination when mixed paper was explored for low temperature conversion pathways and plastics for high temperature conversion pathways. Ink, stickies, and plastic contamination were sorted out of the mixed paper stream and did not have an impact on sugar yields during enzymatic hydrolysis (EH). Although no improvement in yield was found, it was noted that copy paper within the mixed paper stream had an elevated pH and higher concentration of fermentation inhibitors, suggesting that intrinsic properties of some paper types may not be ideal for EH and fermentation conversion. Dilute alkaline pretreatment and mechanical refining of mixed paper increased the EH yield of mixed paper, suggesting this previously established process could be used as a decontamination method. “Dirt” and particulates were washed from mixed plastic using either an aqueous detergent or a non-aqueous chemical washing method. Liquid oil yields were increased during microwave assisted fast pyrolysis. All decontamination techniques met the cost target of less than $30/dry ton with plastic decontamination ranging from $18.16 to $24.81/dry ton. Because dilute alkaline pre-treatment and mechanical refining is considered part of the conversion process, the decontamination cost during feedstock preprocessing was considered $0/dry ton.

Conversion of Paper and Food-rich Municipal Solid Waste Streams to Ethanol Through Bioprocessing

Impact of Blending on Hydrolysis and Ethanol Fermentation of Garden Wastes

Wastes Recycling of Non-Sterile Cellulosic Ethanol Production from Low-Temperature Pilot-Scale Enzymatic Saccharification of Alkali-Treated Sugarcane Bagasse

Bioconversion of Paper Sludge with Low Cellulosic Content to Ethanol by Separate Hydrolysis and Fermentation

Consolidated bioprocessing of the organic fraction of municipal solid waste into bioethanol

Full Components Conversion of Lignocellulose Via a Closed-Circuit Biorefinery Process on a Pilot Scale.

Utilization of food waste for bioethanol production in a circular bioeconomy approach

Efficient Production of Ethanol from Waste Paper and the Biochemical Methane Potential of Stillage Eluted from Ethanol Fermentation.

Whole resource technology for ethanol fermentation from food waste

Enhanced ethanol production from kitchen food waste: Addressing challenges through comprehensive characterization

The Additive Free Microwave Hydrolysis of Lignocellulosic Biomass for Fermentation to High Value Products

BioH2 and bioCH4 recovery by recirculated temperature-phased anaerobic co- digestion of food waste and paper waste

Consolidate Processing for Improvement of Ethanol Production from Food Waste

Decontamination of Mixed Paper and Plastic Municipal Solid Waste Increases Low and High Temperature Conversion Yields

A Citrus Peel Waste Biorefinery for Ethanol and Methane Production

Efficient conversion from food waste to composite carbon source through rapid fermentation and ceramic membrane filtration

Enhanced Productions and Recoveries of Ethanol and Methane from Food Waste by A Three-Stage Process

Anaerobic Co-Digestion of Organic Fractions of Municipal Solid Waste: Synergy Study on Methane Production and Microbial Community

Anaerobic Co-Digestion Of Organic Fractions Of Municipal Solid Waste: Synergy Study Of Methane Production And Microbial Community

Preliminary Discussion on Bioconversion of Municipal Refuse to Ethanol

A Waste-Minimized Biorefinery Scenario for the Hierarchical Conversion of Agricultural Straw into Prebiotic Xylooligosaccharides, Fermentable Sugars and Lithium-Sulfur Batteries