Abstract:To address the trajectory tracking issue of upper-limb rehabilitation exoskeleton with uncertainties and external disturbances, this paper proposes a fractional-order ultra-local model -based model-free finite-time robust controller (FO-FTRC) using predefined performance sliding surface. Different from previous model-free control strategies, a novel multi-input multi-output (MIMO) fractional-order ultra-local model which is a virtual model is proposed to approximate the complex uncertain nonlinear exoskeleton dynamics in a short sliding time window. This allows the design of controller to be independent of any exoskeleton model information and reduces the difficulty of controller design. The developed robust model-free control method incorporates a fractional-order quasi-time delay estimator (FO-QTDE), unknown disturbance estimator (UDE) as well as prescribed performance sliding mode control (PPSMC). The FO-QTDE is utilized to estimate the unknown lumped uncertainties which employs short time delayed knowledge only about the control input. However, the low-pass filter is always added for FO-QTDE when disturbances change fast, which leads to unavoidable estimation error. Then, UDE is designed to further eliminate the estimation error of FO-QTDE to enhance control performance. The PPSMC is constructed to converge sliding surface to zero in a finite time. Besides, the sliding surface is always limited in performance boundaries. After that, the overall system stability and convergence analyses are demonstrated by using the Lyapunov theorem. Finally, with the comparison to other methods of α -variable adaptive model free control ( α -AMFC), time-delay estimation-based continuous nonsingular fast terminal sliding mode controller (TDE-CNFTSMC), time delay estimation (TDE)-based model-free fractional-order nonsingular fast terminal sliding mode control (MFF-TSM) and fractional-order proportion-differential (PD β ), the co-simulation results on 7-degree-of-freedom (DOF) iReHave upper-limb exoskeleton virtual prototype and experiment results on 2-DOF upper-limb exoskeleton are obtained to illustrate the effectiveness and superiority of the proposed FO-FTRC method.

Model-free prescribed performance fixed-time control for wearable exoskeletons

Model-free based fixed-time control for the uncertain wearable exoskeleton with preset performance

Single-input adaptive fuzzy sliding mode control of the lower extremity exoskeleton based on human–robot interaction:

Adaptive robust backstepping force control of 1-dof joint exoskeleton for human performance augmentation

Non-linear Sliding Mode Control of the Lower Extremity Exoskeleton Based on Human–robot Cooperation

Model-free finite-time robust control using fractional-order ultra-local model and prescribed performance sliding surface for upper-limb rehabilitation exoskeleton

Adaptive neural fault-tolerant prescribed performance control of a rehabilitation exoskeleton for lower limb passive training

Fixed‐time observer‐based controller for the human–robot collaboration with interaction force estimation

Tracking Control of Time-Varying Knee Exoskeleton Disturbed by Interaction Torque

Time-varying Stiffness Tracking Control of Knee Exoskeleton

Model‐free prescribed performance fast nonsingular terminal sliding mode control with practical finite‐time stability of uncertain robot manipulators

Model-free Adaptive Iterative Sliding Mode Control for a Robotic Exoskeleton Trajectory Tracking System

Adaptive Event-Triggered Motion Tracking Control Strategy for a Lower Limb Rehabilitation Exoskeleton.

Output Constrained Control of Lower Limb Exoskeleton Based on Knee Motion Probabilistic Model with Finite-Time Extended State Observer

Development, Dynamic Modeling, and Multi-Modal Control of a Therapeutic Exoskeleton for Upper Limb Rehabilitation Training

Multilevel Control Strategy of Human–Exoskeleton Cooperative Motion with Multimodal Wearable Training Evaluation

Adaptive sliding mode control for a lower-limb exoskeleton rehabilitation robot

Model-free Adaptive Trajectory Tracking Control of Robotic Manipulators with Practical Prescribed-Time Performance

Sliding Mode Control for Wearable Exoskeleton Based on Disturbance Observer.

Arm exoskeleton based on model predictive control with input/output feedback linearization

Adaptive disturbance observer-based fixed-time prescribed performance sliding-mode control of uncertain robot manipulators