Abstract:In order to adapt to the high speed of a high-speed permanent magnet synchronous motor (HSPMSM) used in hydrogen fuel cells, air foil bearings are applied to support the motor rotor. However, the stability of the motor rotor system supported by air foil bearings is relatively complex. In this article, the Castigliano's second theorem and the theory of small deflection elastic thin plates are used to establish a deformation model of air foil bearings. Based on the generalized Reynolds equation, the stiffness and damping of the air foil bearings are calculated using perturbation methods and finite difference methods as the support model for the motor rotor. Subsequently, the transfer matrix of a typical disc-shaft unit is analyzed and obtained by using the transfer matrix method. On this basis, combined with Riccati transform, the natural frequencies and critical speeds of the motor rotor system in the spatial domain are calculated using MATLAB. And the unbalanced magnetic pull (UMP) is calculated by Maxwell stress tensor method, which is equivalent to the unbalanced mass and is applied to the disc it acts on to ascertain the unbalanced response, forming a theoretical model for calculating the dynamic performance of high-speed motor rotors. Then, the accuracy of the constructed model is verified by comparing the experimental results with a literature. Based on the estalished model, the effects of structural parameters and operating conditions on motor rotordynamics are studied, and the responses of the motor rotor system to unbalanced mass and unbalanced magnetic tension are compared. It is found that the critical speeds of the motor rotor system increase with the increase of the dynamic viscosity of air, and the motor can operate stably under the influence of the maximum UMP.

Analysis On Dynamical Properties Of The Foil Bearing Rotor System With The Unbalanced Magnetic Pull

Investigation of rotor-gas foil bearing system and its application for an ultra-high-speed permanent magnet synchronous motor

Dynamic Characteristics Analysis of Magnetic Levitation Rotor Considering Unbalanced Magnetic Pull

Rotordynamic Analysis of a Permanent Magnet Synchronous Motor Considering Nonlinear Unbalanced Magnetic Pull

Study on the rotordynamics of a high-speed motor supported by air foil bearings

Rotor dynamic experimental investigation of an ultra-high-speed permanent magnet synchronous motor supported on a three-pad bidirectional gas foil bearing

Study on the Maximum Allowable Unbalance of the High-speed Rotor Based on the Dynamic Load Capacity of Gas Foil Bearings

Investigations on the nonlinear dynamic characteristics of a rotor supported by hybrid foil magnetic bearings

Dynamic Analysis of High Speed Turbine Rotor with Foil Bearing

Design and Function Analysis of Multiphase PM Bearingless Motor with Single Set of Windings

Analysis of High Speed Permanent Magnet Synchronous Motor Rotor Supported by Air Foil Bearings

Feasibility Investigation of a Compressor Rotor Supported by Gas Foil Bearings with Inhomogeneous Bump Foils

DYNAMIC RESEARCH AND DESIGN OF THREE-DIMENSIONAL ALL GAS FOIL BEARING ROTOR SYSTEM

Study on Double-Layer Protuberant Gas Foil Journal Bearings with Different Foil Layers Arrangement

A Novel Method for Calculating the Dynamic Force Coefficients of Gas Foil Bearings and Its Application in the Rotordynamic Analysis

Linear Stability and Nonlinear Rotor Responses of the Gas Foil Bearing with Multiple Sliding Beams

Design and Experimental Verification of the Vehicle Compressor Rotor System with Inhomogeneous Foil Bearings

Transient Line Starting Analysis of the Ultra-High Speed PMSM

A Review on the Dynamic Performance Studies of Gas Foil Bearings

Effect of Unbalanced Magnetic Pull of Generator Rotor on the Dynamic Characteristics of a Pump—Turbine Rotor System

Numerical investigation on the rotordynamics of a high-speed air compressor supported by gas foil bearings