Abstract:The quest for decarbonisation of industry calls for phasing out fossil fuels and in some cases replacing them with green hydrogen in line with the Global Sustainable Goals. To that end novel hydrogen burners will be developed. In this work, the non-premixed combustion of steam-diluted hydrogen combustion is studied numerically in a swirl-stabilised combustor. The flame shape and stabilisation is discussed along with the effects of flow-field, stratification and temperature distribution on the flame. The characteristics of the swirl-stabilised flame is illustrated using several time-averaged and instantaneous contours of parameters including heat-release rate, local equivalence ratio and temperature. The effect of mixing and temperature distribution in the non-premixed configuration is studied quantitatively, subsequently identifying several flame regions. The combustion modes in these regions are also reported. Importantly, neither local hotspots nor flame flashback is observed in this steam-diluted hydrogen combustion. While a typical short hydrogen flame is observed near the centreline of the combustor, a weak V-shaped flame tail also co-exists. The heat-release rate in the flame tail is about two orders of magnitude lower than the main flame. Examining the flame structure using a normalised flame index showed that the combustion in the main flame is premixed-like while that in the main flame is non-premixed. The effect of the flow-field on the transport of fuel and air seems to influence this observation in the flame tail. The high heat-release rate regions of the flame comprised lean ( φ<1 ), moderately hot (T = 800 to 1400 K) mixture. The flame tail region resulted from lean, hot (T >1500 K) mixtures. A flame region with rich mixture ( φ = 1 to 2), featuring moderate heat-release rate, was found to be trapped between an axial fuel jet and the central recirculation region. All these flame regions had flameless combustion as the dominant mode of combustion. In particular, the flame tail region burned completely in the flameless mode. The lean and dominantly flameless combustion in the main flame regions are likely to lead to lower NOx .

Flame Stability Analysis Of Premixed Hydrogen/Air Mixtures In A Swirl Micro-Combustor

Stabilization regimes and pollutant emissions from a dual fuel CH4/H2 and dual swirl low NOx burner

Study of the effect of bluff body size on stability limits of a premixed natural gas swirl burner

Direct Numerical Simulation and Analysis of a Hydrogen/air Swirling Premixed Flame in a Micro Combustor

Effects of flow-flame interactions on the stabilization of ultra-lean swirling CH<sub>4</sub>/H<sub>2</sub>/air flames

Parametric analysis on the combustion and thermal performance of a swirl micro-combustor for micro thermophotovoltaic system

Flame Interaction and Stabilization Mechanisms in a Dual Premix Swirl Combustor with a Pilot Bluff Body

Effect of Channel Diameter on the Combustion and Thermal Behavior of a Hydrogen/Air Premixed Flame in a Swirl Micro-Combustor

Characterisation of non-premixed, swirl-stabilised, wet hydrogen/air flame using large eddy simulation

Investigation on the Effects of Swirl-Strength on Flashback Phenomenon of Premixed CH4/H2/air Flame in a Bluff-Body Swirl Burner

Flame stabilization and formation of flame street in a H 2 /Air non-premixed micro-combustor with a bluff body

The Impact of N2 Micro-Jets on the V-to-M Flame Shape Transition in a Premixed Swirl Burner

The Impact of Preheating on Stability Limits of Premixed Hydrogen–Air Combustion in a Microcombustor

Experimental investigation of combustion characteristics of a CH 4 /O 2 premixed flame: Effect of swirl intensity on flame structure, flame stability, and emissions

Comparative Study of Combustion and Thermal Performance in a Swirling Micro Combustor under Premixed and Non-Premixed Modes

Stabilization and Structure Characteristics of Swirling CH4/H2/O2 Flames Diluted with Steam

Experimental study of compact swirl flames with lean premixed CH4/H2/air mixtures at stable and near blow-off conditions

Effect of Hydrogen Enrichment on Swirl/bluff-Body Lean Premixed Flame Stabilization

A Numerical Study on Non-Premixed H2/air Flame Stability in a Micro-Combustor with a Slotted Bluff-Body

The Role of Flame–flow Interactions on Lean Premixed Lifted Flame Stabilization in a Low Swirl Flow

Experimental Study on Flame Response Characteristics of a Non-Premixed Swirl Model Combustor