Abstract:Gallium nitride (GaN)-based high electron mobility transistor (HEMT) power devices have demonstrated great potential applications due to high current density, high switching speed, and low ON-resistance in comparison to the established silicon (Si)-based semiconductor devices. These superior characteristics make GaN HEMT a promising candidate for next-generation power converters. Many of the early GaN HEMTs are devices with Schottky gate, which suffer a high gate leakage and a small gate swing. By inserting an insulator under gate metal, the MIS-HEMT is highly preferred over the Schottky-gate HEMT for high-voltage power switche, owing to the suppressed gate leakage and enlarged gate swing. However, the insertion of the gate dielectric creates an additional dielectric/(Al) GaN interface that presents some great challenges to AlGaN/GaN MIS-HEMT, such as the threshold voltage (Vth) hysteresis, current collapse and the reliability of the devices. It has been reported that the poor-quality native oxide (GaOx) is detrimental to the dielectric/(Al) GaN interface quality that accounted for the Vth instability issue in the GaN based device. Meanwhile, it has been proved that in-situ plasma pretreatment is capable of removing the surface native oxide. On the other hand, low power chemical vapor deposition (LPCVD)-Si3N4 with free of plasma-induced damage, high film quality, and high thermal stability, shows great potential applications and advantages as a choice for the GaN MIS-HEMTs gate dielectric and the passivation layer. In this work, an in-situ pre-deposition plasma nitridation process is adopted to remove the native oxide and reduce surface dangling bonds prior to LPCVD-Si3N4 deposition. The LPCVD-Si3N4/GaN/AlGaN/GaN MIS-HEMT with a high-quality LPCVD-Si3N4/GaN interface is demonstrated. The fabricated MIS-HEMT exhibits a very-low Vth hysteresis of 186 mV at VG-sweep=(-30 V, +24 V), a high breakdown voltage of 881 V, with the substrate grounded. The hysteresis of our device at a higher positive end of gate sweep voltage (VG +20 V) is the best to our knowledge. Switched off after an off-state VDS stress of 400 V, the device has a dynamic on-resistance Ron only 36% larger than the static Ron.

Precise Measurement Methodology of nH-level Gate Electrode Inductance Based on Calculation-error-free Algorithm for Unity-gain Turn-off Devices

A New Method to Extract Gate Bias-Dependent Parasitic Resistances in GaAs Phemts

A New Extraction Method of GaN Switch-Hemt Small-Signal Model with Capacitance Scanning Algorithm

A Simple Measurement Method of Common Source Inductance for GaN Devices

A Normalized Quantitative Method for GaN HEMT Turn-ON Overvoltage Modeling and Suppressing

On-The-Fly Interface Trap Measurement And Its Impact On The Understanding Of Nbti Mechanism For P-Mosfets With Sion Gate Dielectric

Stray Impedance Measurement and Improvement of High-Power IGCT Gate Driver Units

A High-Bandwidth and Easy-to-Integrate Parasitics-Based Switching Current Measurement Method for Fast GaN Devices

Influence of Gate Loop Inductance on TSEP-Based Junction Temperature Monitoring for IGBT

Adaptive Stray Inductance Extraction Algorithm Using Linear Regression for Power Module with High Noise Immunity and Accuracy

Analysis and Suppression of High Speed Dv/Dt Induced False Turn-on in GaN HEMT Phase-Leg Topology

Improved Measurement Accuracy for Junction-to-Case Thermal Resistance of GaN HEMT Packages by Gate-to-Gate Electrical Resistance and Stacking Thermal Interface Materials

Accurate SiC MOSFET Chip V<sub>gs</sub> Extraction Based on Parasitic Parameter Impact Compensation

Accurate SiC MOSFET Chip Extraction Based on Parasitic Parameter Impact Compensation

Study on the Measurement Accuracy of Circular Transmission Line Model for Low-Resistance Ohmic Contacts on III-V Wide Band-Gap Semiconductors

Investigation of contact mechanism and gate electrostatic control in multi-channel AlGaN/GaN high electron mobility transistors with deep recessed ohmic contact

Accurate SiC MOSFET Chip Extraction Based on Parasitic Parameter Impact Compensation<italic/><sub/>

Gate Robustness and Reliability of P-Gate GaN HEMT Evaluated by a Circuit Method

High-performance AlGaN/GaN MIS-HEMT Device Based on in Situ Plasma Nitriding and Low Power Chemical Vapor Deposition Si3N4 Gate Dielectrics

An Improved Method for InP HEMT Noise-Parameter Determination Based on 50-Ω Noise Measurements

Characterization of Gate Leakage and Reliability of Normally-OFF GaN MOSFET with LPCVD-SiN<sub><i>x</i></sub>/PEALD-AlN Dual Gate Dielectric and <i>In-Situ</i> H<sub>2</sub>(15%)/N<sub>2</sub>(85%) Plasma Pretreatment