Abstract:Improving the fire resistance of polymeric materials is an important research problem, which is solved using various flame retardants. Organophosphorus compounds are among the most effective and en-vironmentally friendly flame retardants. This paper reports an experimental, theoretical, and kinetic modeling study of the conversion of triphenyl phosphate (TPP) during thermal decomposition in an inert medium, i.e., under conditions typical of the flame zone near the polymer surface. Pyrolysis of TPP vapor was examined in a thermal reactor under argon flow at a pressure of 1 atm. The temperature dependence of the composition of TPP pyrolysis products leaving the thermal reactor was investigated by molecular beam mass spectrometry in the temperature range of 50 0-130 0 K. The geometry of all structures on the potential energy surfaces of TPP and primary and secondary decomposition products of TPP was optimized using density functional theory (DFT) (omega B97XD) with the 6-31G(d) basis set. The kinetic rate constants of the thermal decomposition reactions of TPP were calculated using the Rice-Ramsperger-Kassel-Marcus theory with the master kinetic equation (RRKM-ME) implemented in the MESS code, and thermochemical parameters were obtained for TPP and primary and secondary decomposition products of TPP in the temperature range of 20 0-60 0 0 K. A detailed chemical kinetic mechanism for TPP pyrolysis was developed by combining the primary TPP decomposition reaction path-ways with the rate parameters derived from the theoretical calculations and submechanisms available in the literature for the conversion of the phenyl and phenoxy radicals and phosphorus containing products. The proposed kinetic mechanism quantitatively reproduces the measured temperature-resolved TPP mole fraction profile at the reactor outlet. The mechanism also provides a good fit to the experimentally observed trends in the conversion of major phosphorus-containing intermediates detected in this work. (c) 2023 The Combustion Institute. Published by Elsevier Inc. All rights reserved.

Studies on Multistep Thermal Decomposition Behavior of Polytriazole Polyethylene Oxide‐tetrahydrofuran Elastomer

Thermal Stability of Aromatic Polyesters Prepared from Diphenolic Acid and Its Esters

Atomic insights into the thermal degradation of polyethylene terephthalate combining STA-FTIR and DFT methods

Non-isothermal Decomposition Kinetics and Lifetime of Polyoxypropylene Ether

Effects of Dibenzocrown Ether and Diphenoxyethylene Diether Structural Units on the Properties of Degradable Polyhexahydrotriazine Thermosetting Resins

Influence of Triphenyl Phosphate on Degradation Kinetics of Ultrahigh-molecular-weight Polyethylene in Inert and Oxidative Media

Thermal Characteristics of Energetic Polymers Based on Tetrahydrofuran and Oxetane Derivatives

Investigation on the thermal decomposition of the elastomer containing fluoroolefin segment by DSC‐TG‐MS‐FTIR

Polytetrafluoroethylene decomposition in air and nitrogen

Thermal decomposition of flexible polyurethane foam under nitrogen and air atmospheres: Thermogravimetric analysis by ETp method

Thermal degradation of typical plastics under high heating rate conditions by TG-FTIR: Pyrolysis behaviors and kinetic analysis

Mechanical Properties and Thermal Decomposition Mechanism of Glycidyl Azide Polyol Energetic Thermoplastic Elastomer Binder with RDX Composite

Study on the Thermal Stability of Dicumyl Peroxide

High-temperature Thermal Decomposition of Triphenyl Phosphate Vapor in an Inert Medium: Flow Reactor Pyrolysis, Quantum Chemical Calculations, and Kinetic Modeling

Thermal Hazard Analysis and Initial Decomposition Mechanism of 5-(4-pyridyl)tetrazolate-methylene Tetrazole

Thermal Instability and Kinetics Analysis on Triacetone Triperoxide (TATP)

Thermal properties and degradation of polytetrafluoroethylene low‐molecular fractions

Thermal hazard and mechanism study of 5-(4-Pyridyl)tetrazolate (H4-PTZ)

Thermo‐oxidative degradation of ultrahigh molecular weight poly(ethylene oxide) in volatile organic solvents

Mechanisms and Kinetics Studies on the Thermal Decomposition of Micron Poly (methyl Methacrylate) and Polystyrene

A study on the decomposition pathways of HTPB and HTPE pyrolysis by mass spectrometric analysis