Abstract:Two laboratory-scale, first-stage, Autothennal Thermophilic Aerobic Digestion (ATAD) reactors which were configured in parallel were used to determine optimum sludge residence time (SRT) and aeration rates to achieve maximum pathogen reduction and best process performance. Feed sludge had to thicken by gravity because a minimal quantity of organic material is needed to sustain self-heating. In this experiment solid ratio ranged within 2% to 7%. Total solids (TS), volatile solids (VS), and volatile Suspended solids (VSS) destruction rate reached 41.5%, 43.8%, and 48.6% in digestion time of 7 d when the air supply was at 1.0 volume of air per volume of secondary sludge per hour (vvh) aeration rate. The effect of aeration rate was studied at 0.5, 1.0, 1.5 and 2.0 vvh at unregulated pH, while pH always rise from 6.4 to 8.0 in differing experimental conditions. Medium aeration rate (0.75 vvh -1.5 vvh) and SRT (6 d-8 d) were efficient and economic. ATAD at temperatures >= 45 degrees C and SRT >= 4 day reduced the feed sludge fecal coliform density from 10(7) MPN/g TS to <10(3) MPN/g TS. Salmonella in the feed sludge was reduced to <1 MPN/4 g TS from 6 to 20 MPN/4 g TS by ATAD at temperatures >= 45 degrees C and SRT >= 5 d. The study revealed when the sludge was not stabilized and the ratio between total chemical oxygen demand (COD) and TS were high. As the experiment progressed and the sludge became stabilized, this quotient was gradually reduced. From the results, a good correlation coefficient was recorded between both COD/TS and VSS destruction rate curves over the course, COD/TS ratio might be used to estimate the degree of biosolids stability as a complementary tool compared with the routine parameters (VSS destruction rates, the special oxygen uptake rate), due to its simplicity, speed and low costs.

Effect of temperature and SRT on thermophilic aerobic digestion

Effect of Atuothermal Thermophilic Aerobic Digestion operation on reactor temperatures

Effect of Temperature on Municipal Wastewater Treatment in Modified Expanded Granular Sludge Bed

Effect of Thermal-alkaline Pretreatment on Anaerobic Digestion of Sludge with Low Organic Content

Effects of low- and high-temperature thermal-alkaline pretreatments on anaerobic digestion of waste activated sludge

Waste Activated Sludge Treatment Based on Temperature Staged and Biologically Phased Anaerobic Digestion System.

Ultrasonic-pretreated waste activated sludge hydrolysis and volatile fatty acid accumulation under alkaline conditions: Effect of temperature.

Pilot-scale Test on Sludge Stabilization by Using Autothermal Thermophilic Aerobic Digestion Process

Effects of Mild Thermal Pretreatment on Anaerobic Digestibility of Sludge with Low Organic Content

Effects of Thermal Hydrolysis on the Metabolism of Amino Acids in Sewage Sludge in Anaerobic Digestion.

Effect of thermal hydrolysis pretreatment on the stabilization of sludge with different solid contents during autothermal thermophilic aerobic digestion

[Pilot Study of Thermal Treatment/thermophilic Anaerobic Digestion Process Treating Waste Activated Sludge of High Solid Content].

Waste activated sludge hydrolysis and short-chain fatty acids accumulation in the presence of SDBS in semi-continuous flow reactors: Effect of solids retention time and temperature

Chemical and microbial changes during autothermal thermophilic aerobic digestion (ATAD) of sewage sludge.

An Effective Technology To Produce Biosolid For Land Application: Autothermal Thermophilic Aerobic Digestion Process

Short-time Aerobic Digestion Treatment of Waste Activated Sludge to Enhance EPS Production and Sludge Dewatering Performance by Changing Microbial Communities: the Impact of Temperature

Effects of Sludge Properties in a Combined Process of Mesophilic Anaerobic Digestion and Thermophilic Aerobic Digestion

Untangling the effect of solids content on thermal-alkali pre-treatment and anaerobic digestion of sludge

The Study of Sludge Characteristics for One-Stage Autothermal Thermophilic Aerobic Digestion Process

EFFECT OF AERATION RATE ON PILOT TECHNOLOGICAL PROCESS OF AUTOTHERMAL THERMOPHILIC AEROBIC DIGESTION(ATAD)

Two-phase High Solid Anaerobic Digestion with Dewatered Sludge: Improved Volatile Solid Degradation and Specific Methane Generation by Temperature and Ph Regulation