Abstract:Diosgenin (CAS No.: 512-04-9) hydrolyzed from Dioscorea zingiberensis C. H. Wright is a very important steroid in the pharmaceutical industry. However, serious environmental pollution and poor efficiency in the utilization of this natural resource have yet to be conquered. The aim of this study was to establish a more ecological and efficient approach for producing diosgenin from fresh D. zingiberensis tubers via pressurized biphase acid hydrolysis after recycling the cellulose and starch. The reaction was carried out in a high pressure kettle, and seven parameters, including the sample to acidic solution ratio, concentration of H2SO4 aqueous solution, volume of extraction solvent, reaction temperature, duration of hydrolysis, agitation speed and boiling point of petroleum ether, were sequentially optimized through single factor experimental design. It was shown that the yield of diosgenin has been increased to 4.17% under the optimal conditions, namely, a 1:100 ratio of saponini/acidic solution (g/mL), 50 mL of 2 mu L/mL H2SO4 aqueous solution, 30 mL of petroleum ether (90-120 degrees C), 130 degrees C, 2.0 h and 100 r/min. Then, the newly proposed approach was compared with our previous strategy as well as a conventional method in terms of the yield of diosgenin, the consumption of sulfuric acid and chemical oxygen demand as well as total organic carbon of wastewater. Consequently, it was found that the yield was 22.29% higher than the conventional process, and H2SO4 consumption was reduced by 88.53%. Furthermore, the level of pollution in wastewater of the novel strategy has fallen greatly as the chemical oxygen demand and the total organic carbon were decreased by 50.15% and 64.39%. Comprehensively, it has been well demonstrated that the novel strategy based on pressurized biphase acid hydrolysis after recycling the cellulose and starch is a more ecological and effective approach for producing diosgenin from the tubers of fresh D. zingiberensis, and it is a promising strategy for application in industrial practice. (C) 2016 Elsevier Ltd. All rights reserved.

Green Production of Diosgenin from Alcoholysis of Dioscorea Zingiberensis C. H. Wright by a Magnetic Solid Acid

Catalytic alcoholysis of saponins in <i>D</i>. <i>zingiberensis</i> <i>C</i>. <i>H</i>. <i>Wright</i> (Curcuma longa L) with magnetic solid acid to prepare diosgenin by response surface methodology

Efficient Alcoholysis of Total Saponins in D. Zingiberensis C. H. Wright with Novel Magnetic Solid Acids Through a Cleaner Approach

Magnetically Recyclable Solid Acid Catalyst Fe3O4@ETMS-TETA-SO3H for Efficient Alcoholysis of Dioscin from Dioscorea Zingiberensis C.H.Wrigh

Polymer-based solid acid catalyst for the green production of diosgenin

Efficient Alcoholysis of Saponins from Dioscorea Zingiberensis by Solid Acids Derived from Diethylenetriamine

Synthesis and Characterization of Magnetic Solid Acid Fe3O4@PEI@SO3H and Application for the Production of Diosgenin by Alcoholysis of Turmeric Saponins

Alcoholysis approach for an efficient and cleaner production of diosgenin by low cost and green carbon based solid acids from biomass residues

Oxidative Lactonization of Diethylene Glycol to High-Value-added Product 1, 4-Dioxan-2-one Promoted by a Highly Efficacious and Selective Catalyst ZnO-ZnCr2O4

Green Conversion of Saponins to Diosgenin in an Alcoholysis System Catalyzed by Solid Acid Derived from Phosphorus Tailings

A More Ecological and Efficient Approach for Producing Diosgenin from Dioscorea Zingiberensis Tubers Via Pressurized Biphase Acid Hydrolysis

Novel Method Utilizing Microbial Treatment for Cleaner Production of Diosgenin from Dioscorea Zingiberensis Ch Wright (Dzw)

A promising clean process for production of diosgenin from Dioscorea zingiberensis C. H. Wright

Ultrasonic And Fermented Pretreatment Technology For Diosgenin Production From Diosorea Zingiberensis Ch Wright

Efficient Alcoholysis of Total Saponins in D. Zingiberensis to Diosgenin Using Ionic Liquid-Grafted MOF Superacids

Preparation of Poly (styrene‐co‐allyl Sulfonic Acid) As a Novel Catalyst for the Alcoholysis of Dioscin

Synthesis and Characterization of SO3H-functionalized Silica Solid Acid Catalyst and Application for the Production of Diosgenin

In Situ Pressurized Biphase Acid Hydrolysis, A Promising Approach To Produce Bioactive Diosgenin From The Tubers Of Dioscorea Zingiberensis

Green Production of Diosgenin from Discorea Nipponica Makino Tubers Based on Pressurized Biphase Acid Hydrolysis Via Response Surface Methodology Optimization

Production of diosgenin from Dioscorea zingiberensis tubers through enzymatic saccharification and microbial transformation

Diosgenin Extracting from Dioscore Azingiberensis Wright by Compound Microorganisms Fermentation Method