Abstract:Although syngas combustion has been extensively investigated, previous studies did not systematically examine the fuel-NOx formation from ammonia-containing syngas in both N2 and CO2 atmospheres. Investigations on syngas-ammonia oxidation are significant for suppressing the fuel-NOx emission from the combustion of actual syngas containing NH3. This study presents new experimental results on syngas-ammonia oxidation under both N2 and CO2 atmospheres in a jet-stirred reactor. The effects of CO2 concentration (XCO2: 0–60%), temperature (T: 900–1400 K), equivalence ratio (Φ: 0.4–1.65), initial CH4 concentration (XCH4: 0–2000 ppm), CO/H2 ratio, and residence time (τ: 0.001–10 s) are investigated. For the oxidation of syngas-ammonia, the reactant consumption is delayed and more CO is produced in high CO2 concentration. A critical temperature to obtain the peak N2O production is found, and it is slightly reduced from 1000 to 950 K with Φ increasing from 0.63 to 1.25. Moreover, the N2O concentration is basically insensitive to the concentration of CH4 and the CO/H2 ratio in syngas. The NO production is enhanced with the increase of T, XCH4, and the CO/H2 ratio, while it is reduced with increasing Φ. Interestingly, the high concentration of CO2 suppresses the fuel-NO formation in fuel-lean conditions, while it significantly enhances the fuel-NO production in fuel-rich conditions. To minimize emissions of NO, N2O, and CO, it is recommended to operate the reaction at T > 1000 K and simultaneously avoid significantly high temperatures at the equivalence ratio of approximately 0.9, low values of initial CH4 concentration and the CO/H2 ratio (e.g., <1), long residence times (τ > 2 s), and high concentrations of CO2 (XCO2 > 30%). Furthermore, the numerical simulations agree well with the vast majority of measurements, and the dependence of NO on Φ at XCO2 = 30% is also well predicted. The present study provides new fundamental understandings of the fuel-NOx formation from ammonia-containing syngas.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.energyfuels.1c00647?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.energyfuels.1c00647</a>.Verification of the JSR design and effects of N2 and CO2 on the NO formation from syngas-ammonia (<a class="ext-link" href="/doi/suppl/10.1021/acs.energyfuels.1c00647/suppl_file/ef1c00647_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Studies of High-Pressure N-Butane Oxidation with CO2 Dilution Up to 100 Atm Using a Supercritical-Pressure Jet-Stirred Reactor

Effect of Pressure and CO2 Dilution on Soot Formation in Laminar Inverse Coflow Flame at Conditions Close to Autothermal Reforming

The Effects of CO2/CH4 Ratio on Soot Formation for Autothermal Reforming of Methane at Elevated Pressure

Low- and intermediate-temperature oxidation of dimethyl ether up to 100 atm in a supercritical pressure jet-stirred reactor

Variable pressure JSR study of low temperature oxidation chemistry of n-heptane by synchrotron photoionization mass spectrometry

Detailed Product Analysis During the Low Temperature Oxidation of N-Butane

Low-temperature oxidation of n -butanol in a jet-stirred reactor: Detailed species measurements and modeling studies

Experimental and modeling study of ignition delay times of n-C5H12 and C3H6 under O2/CO2 atmospheres

Revisiting low temperature oxidation chemistry of n-heptane

Experimental and Model Investigation of the Low Temperature Oxidation and Pyrolysis of 2-Methyl-2-butene in a Jet-Stirred Reactor

Experimental and numerical study of the effect of H2O and CO2 dilution on NH3/CH4 co-oxidation characteristics in a jet-stirred reactor

Experimental and Chemical Kinetic Study on the Low Temperature Oxidation of 1,3-Butadiene in a Jet-Stirred Reactor

Experimental and Kinetic Study on Low Temperature Oxidation and Pyrolysis of Iso-Octane and Gasoline

Experimental and Modeling Study of N-Butanol Oxidation at High Temperature

Investigation of the Low-Temperature Oxidation of N-Butanal in a Jet-Stirred Reactor

An Experimental and Kinetic Modeling Investigation on Low‐temperature Oxidation Chemistry of 1,3,5‐trimethylcyclohexane in a Jet‐stirred Reactor

Experimental and kinetic modeling study of ethylene oxidation at elevated pressure

Experimental and Kinetic Study on the Pyrolysis and Oxidation of Isopentane in a Jet-Stirred Reactor

Revisit to the oxidation of CH4 at elevated pressure

Experimental and Kinetic Study on the Oxidation of Syngas-Ammonia under Both N 2 and CO 2 Atmospheres in a Jet-Stirred Reactor

Synchrotron Vacuum Ultraviolet Photoionization Mass Spectrometry and Modeling Study of Iso-Octane Low Temperature Oxidation at Varied Pressures