Abstract:Natural gas (NG) requires treatment to eliminate sulphur compounds and acid gases, including carbon dioxide (CO2) and hydrogen sulphide (H2S), to ensure that it meets the sale and transportation specifications. Depending on the region the gas is obtained from, the concentrations of acid gases could reach up to 90%. Different technologies are available to capture CO2 and H2S from NG and absorb them with chemical or physical solvents; occasionally, a mixture of physical and chemical solvents is employed to achieve the desired results. Nonetheless, chemical absorption is the most reliable and utilised technology worldwide. Unfortunately, the high energy demand for solvent regeneration in stripping columns presents an obstacle. Consequently, the present study proposes a novel, ternary-hybrid mixture of N-methyl diethanolamine (MDEA), amino ethyl ethanol amine (AEEA), and N-methyl 2-pyrrolidone (NMP) to overcome the issue and reduce the reboiler duty. The study employed high levels of CO2 (45%) and H2S (1%) as the base case, while the simulation was performed with the Aspen HYSYS® V12.1 software to evaluate different parameters that affect the reboiler duty in the acid gas removal unit (AGRU). The simulation was first validated, and the parameters recorded errors below 5%. As the temperature increased from 35 °C to 70 °C, the molar flow of the CO2 and H2S in sweet gas also rose. Nevertheless, the pressure demonstrated an opposite trend, where elevating the pressure from 1000 kPa to 8000 kPa diminished the molar flow of acid gases in the sweet gas. Furthermore, a lower flow rate was required to achieve the desired specification of sweet gas using a ternary-hybrid blend, due to the presence of a higher physical solvent concentration in the hybrid solvent, thus necessitating 64.2% and 76.8%, respectively, less reboiler energy than the MDEA and MDEA + AEEA.

Experimental Study on Removal of H2s Using Mdea Solution in Microchannel

Experimental study on absorption of H2S in T-junction microchannel

Selective Absorption of H2S from a Gas Mixture with CO2 in a Microporous Tube-in-tube Microchannel Reactor

Experimental Study on Volatile Sulfur Compound Inhibition Using a Single-Chamber Membrane-Free Microbial Electrolysis Cell

Experimental Study on the Treatment of Odor Gas Containing Hydrogen Sulfide by Immobilized Microorganisms

Experimental study on removal of hydrogen sulfide gas by spray and bubble blowing: A comparative study

Absorption study of acid gas in nature gas by sterically hindered amine TBEE

Study on Absorption Selectivity of Absorbents for Organic Sulfide in High Sour Natural Gas

Effect of acidic products from degradation of N-methyldiethanolamine amine on CO2/H2S capturing from natural gas

Calculation of gas solubility in the system MDEA-H2O-CO2-H2S

Influence of MEA and piperazine additives on the desulfurization ability of MDEA aqueous for natural gas purification

Experimental Study of Uds Solvents for Purifying Highly Sour Natural Gas at Industrial Side-Stream Plant

Calculation of gas solubility in the system MDEA-H;O-CO;-H;S

Investigation into the Enhancement of Gas-Liquid Mass Transfer of Absorption of H 2 S by MDEA with Carbon Quantum Dots

Energy Saving during Gas Desulfurization by MDEA Absorption

Selective Removal of H2S over CO2 in a Membrane Gas–liquid Microdisperison Microreactor

A novel process of low-temperature fractionation combined with extractive distillation for H2S removal from natural gas

A Study on Performances of Acidic Gases Absorption into Aqueous Solution of MDEA-TBEE Complex Solvents

A Study on the Desulfurization Performance of Solvent UDS for Purifying High Sour Natural Gas

Hydrogen sulfide removal from biogas in anaerobic fermentation by use of biological process

Simulation of Natural Gas Treatment for Acid Gas Removal Using the Ternary Blend of MDEA, AEEA, and NMP