Abstract:An innovative approach has been recently proposed in order to link polyhydroxyalkanoates (PHA) production with sludge minimization in municipal wastewater treatment, where (1) a sequencing batch reactor (SBR) is used for the simultaneous municipal wastewater treatment and the selection/enrichment of biomass with storage ability and (2) the acidogenic fermentation of the primary sludge is used to produce a stream rich in volatile fatty acids (VFAs) as the carbon source for the following PHA accumulation stage. The reliability of the proposed process has been evaluated at lab scale by using substrate synthetic mixtures for both stages, simulating a low-strength municipal wastewater and the effluent from primary sludge fermentation, respectively. Six SBR runs were performed under the same operating conditions, each time starting from a new activated sludge inoculum. In every SBR run, despite the low VFA content (10 % chemical oxygen demand, COD basis) of the substrate synthetic mixture, a stable feast–famine regime was established, ensuring the necessary selection/enrichment of the sludge and soluble COD removal to 89 %. A good process reproducibility was observed, as also confirmed by denaturing gradient gel electrophoresis (DGGE) analysis of the microbial community, which showed that a high similarity after SBR steady-state had been reached. The main variation factors of the storage properties among different runs were uncontrolled changes of settling properties which in turn caused variations of both sludge retention time and specific organic loading rate. In the following accumulation batch tests, the selected/enriched consortium was able to accumulate PHA with good rate (63 mg CODPHA g CODXa−1 h−1) and yield (0.23 CODPHA CODΔS−1) in spite that the feeding solution was different from the acclimation one. Even though the PHA production performance still requires optimization, the proposed process has a good potential especially if coupled to minimization of both primary sludge (by its use as the VFA source for the PHA accumulation, via previous fermentation) and excess secondary sludge (by its use as the biomass source for the PHA accumulation).

Polyhydroxyalkanoates (PHA) production by mixed cultures fed by excess sludge fermentation liquid

Optimal Production of Polyhydroxyalkanoates (pha) in Activated Sludge Fed by Volatile Fatty Acids (vfas) Generated from Alkaline Excess Sludge Fermentation

Coupling of Polyhydroxyalkanoate Production with Volatile Fatty Acid from Food Wastes and Excess Sludge

Polyhydroxyalkanoate production from fermented volatile fatty acids: effect of pH and feeding regimes.

Influence of Substrate Load on Polyhydroxyalkanoates (pha) Accumulation by Unenriched Mixed Cultures from Excess Sludge Fermentation Liquid

Production of Polyhydroxyalkanoates (PHA) by Bacterial Consortium from Excess Sludge Fermentation Liquid at Laboratory and Pilot Scales

Polyhydroxyalkanoate (PHA) production with acid or alkali pretreated sludge acidogenic liquid as carbon source: Substrate metabolism and monomer composition

Efficient Polyhydroxyalkanoates Production From A Waste-Activated Sludge Alkaline Fermentation Liquid By Activated Sludge Submitted To The Aerobic Feeding And Discharge Process

Overall Process of Using a Valerate-Dominant Sludge Hydrolysate to Produce High-Quality Polyhydroxyalkanoates (PHA) in a Mixed Culture

Transformation and composition of polyhydroxyalkanoate by glycogen-accumulating organisms enriched activated sludge affected by different propionate to acetate ratios

Reducing the effect of non-volatile fatty acids (non-VFAs) on polyhydroxyalkanoates (PHA) production from fermented thermal-hydrolyzed sludge.

Polyhydroxyalkanoate (PHA) production in open mixed cultures using waste activated sludge as biomass

Enriching Polyhydroxyalkanoates (PHA) Producing Microorganisms by Complex Organics from Quickly Alkaline Fermentation Liquor

Effect of composition of volatile fatty acids on yield of polyhydroxyalkanoates and mechanisms of bioconversion from activated sludge

Effects of the Sludge Retention Time and Carbon Source on Polyhydroxyalkanoate-Storing Biomass Selection under Aerobic-Feast and Anoxic-Famine Conditions

Polyhydroxyalkanoates production by Ralstonia eutropha H16 fed by waste sludge anaerobic fermentative liquid

Insights into enhanced polyhydroxyalkanoate production by the synergistic use of waste wood hydrolysate and volatile fatty acids by mixed microbial cultures

Poly(3-hydroxybutyrate-3-hydroxyvalerate) production from pretreated waste lignocellulosic hydrolysates and acetate co-substrate

Optimization of polyhydroxyalkanoates (PHA) synthesis with heat pretreated waste sludge.

Enhanced Polyhydroxyalkanoate Production by Mixed Microbial Culture with Extended Cultivation Strategy

Sludge minimization in municipal wastewater treatment by polyhydroxyalkanoate (PHA) production