Abstract:Semiconductor oxides are frequently used as active photocatalysts for the degradation of organic agents in water polluted by domestic industry. In this study, sol-gel ZnO thin films with a grain size in the range of 7.5–15.7 nm were prepared by applying a novel two-step drying procedure involving hot air treatment at 90–95 °C followed by conventional furnace drying at 140 °C. For comparison, layers were made by standard furnace drying. The effect of hot air treatment on the film surface morphology, transparency, and photocatalytic behavior during the degradation of Malachite Green azo dye in water under ultraviolet or visible light illumination is explored. The films treated with hot air demonstrate significantly better photocatalytic activity under ultraviolet irradiation than the furnace-dried films, which is comparable with the activity of unmodified ZnO nanocrystal powders. The achieved percentage of degradation is 78–82% under ultraviolet illumination and 85–90% under visible light illumination. Multiple usages of the hot air-treated films (up to six photocatalytic cycles) are demonstrated, indicating improved photo-corrosion resistance. The observed high photocatalytic activity and good photo-corrosion stability are related to the hot air treatment, which causes a reduction of oxygen vacancies and other defects and the formation of interstitial oxygen and/or zinc vacancies in the films.

Preparation of Visible-light Response Nano-sized ZnO Film and Its Photocatalytic Degradation to Methyl Orange

Preparation of Aluminum Foil-Supported Nano-Sized ZnO Thin Films and Its Photocatalytic Degradation to Phenol under Visible Light Irradiation

Preparation of TiO_2/ZnO nano porous film and its photodegradation behavior on methyl orange

Photocatalytic Degradation of Methyl Orange on ZnO in Aqueous

NS-ZnO@P–Zn Nanocomposites Catalysts with Superior Photodegradation of Methyl Orange Through In-Situ Oxidation and Ph-Mediated Dealloying of Equiatomic Al50Zn50 Precursors

Photocatalyst of TiO2/ZnO Nano Composite Film: Preparation, Characterization, and Photodegradation Activity of Methyl Orange

Study on Preparing Photo-Catalysis of ZnO Carried by Natural Zellites

Preparation,Characterization and Photocatalytic Performance of ZnO Nano-Flakes

Enhanced Photocatalytic Performance under Ultraviolet and Visible Light Illumination of ZnO Thin Films Prepared by Modified Sol-Gel Method

Synthesis and Recycle of ZnO Particles for Degradation of Methyl Orange Aqueous Solution

Enhanced Visible-Light-driven Photocatalytic Removal of Refractory Pollutants by Zn/Fe Mixed Metal Oxide Derived from Layered Double Hydroxide

Preparation of ZnFe2O4 nanometer films by sol-gel method and study of its photoelectrocatalytic properties

Photocatalytic Activity of Cu2O/ZnO Nanocomposite for the Decomposition of Methyl Orange under Visible Light Irradiation

Comparative Studies on Degradation of Methyl Orange by Nanostructured Zinc and Zinc Oxide Films

Visible-light-driven Photodegradation of Methyl Orange Using Cu2O/ZnAl Calcined Layered Double Hydroxides As Photocatalysts

Synthesis and Characterization of Co–ZnO and Evaluation of Its Photocatalytic Activity for Photodegradation of Methyl Orange

Preparation and photocatalytic properties of ZnO nanorod array films produced by a low-temperature wet-chemical method

Ag-Loaded ZnO Nanocomposite Films as Photocatalysts for the Degradation of Pigments under Visible Light

Preparation of TiO2 Nanofilm Via Sol–gel Process and Its Photocatalytic Activity for Degradation of Methyl Orange

Preparation Of(fe, Ni)-Codoped ZnO and Its Photocatalytic Activity for Degradation of Methyl Orange

Photocatalytic Degradation of Methyl Orange Using ZnO/TiO2 Composites