Abstract:Oxy-coal combustion steam system of near-zero emission (OCCSS) proposed by the authors' research group is a new power generation system which uses coal-based syngas or demineralized coal as fuel. The combustion process has the characteristics of high temperature, high pressure, high water vapor concentration and high oxygen concentration. The key point of understanding the combustion process is to study the combustion characteristics under complex conditions. As an important part of the combustion characteristics, the study of the flammable limit of syngas has important value for the design and operation of the burner. The paper introduces the study of the lower flammability limit (LFL) of hydrogen/carbon monoxide mixtures (H-2/CO) based on a spherical explosion vessel. The internal diameter was 337 mm and the volume is 20.04 L. The experimental procedure was based upon ASTM E2079-07. Effects of initial temperature, H-2/CO ratio, and different dilution with N-2 or water vapor were studied. Results show LFL of the syngas decreases with the temperature, which indicates higher initial temperature can promote flame propagation. The study also shows the flame temperature at LFL is approximately constant regardless of the unburned gas temperature. Experiments on the effects of different H-2 contents both which is from 0 to 100% in both pure oxygen and water vapor show more H-2 in the mixed gas will help to lower the LFL, and the presence of H2O can promote the flame propagation. In addition, studies on the dilution effects of H2O and N-2 on LFL show the addition of water vapor not only reduces the reactant concentration, but also affects the gas flame propagation through affecting the chemical process. Finally, Le Chatelier's rule is used to estimate the LFL of the H-2/CO mixture and compared with the experimental data. The results indicate the mixing rule is appropriate for the predication of LFL of H-2/CO in O-2/H2O environment by considering N-2 or CO2 as a kind of dilution in the combustible gas. (C) 2017 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved.

On the explosion limits of H2/CO/O2 mixtures

On Explosion Limits of H2/CO/O2 Mixtures

Analytical explosion limits of H2/CO/O2 and H2/CH4/O2 mixtures

On the explosion limit of syngas with CO 2 and H 2 O additions

Explosion Limits of H2/CH4/O2 Mixtures: Analyticity and Dominant Kinetics

Effects of H2/CO ratio and CO2 dilution on the explosion behavior and flame evolution of syngas/air mixtures

Pressure History in the Explosion of Moist Syngas/air Mixtures

On the Z-shaped Explosion Limits of Acetylene-Oxygen Mixtures

Explosion Behavior Predictions of Syngas/air Mixtures with Dilutions at Elevated Pressures: Explosion and Intrinsic Flame Instability Parameters

Explosion characteristics of bio-syngas at various fuel compositions and dilutions in a confined vessel

On the Explosion Characteristics of Natural Gas with Hydrogen and Inert Gas Additions

Numerical Study on Explosion Limits of Ammonia/hydrogen/oxygen Mixtures: Sensitivity and Eigenvalue Analysis

On Explosion Limits of Ammonia–Oxygen Mixtures with Hydrogen Addition: Sensitivity and Nonmonotonicity

Experimental Study of the Effect of CO/H2 Ratio and Release Pressure on Syngas Jet Flame Propagation and Overpressure

On Explosion-Limit Regime Diagram of H2 and C1 to C3 Alkanes with Unified Pivot State

Explosion Limits of Hydrogen/oxygen Mixtures with Nitric Oxide Sensitization

Experimental Study of the Influence of H2/CO on the CH4 Explosion Pressure and Thermal Behaviors

Quantitative investigation of explosion behavior and spectral radiant characteristics of free radicals for syngas/air mixtures

Study on the Lower Flammability Limit of H-2/Co in O-2/H2o Environment

A comparative study on the turbulent explosion characteristics of syngas between CO-enriched and H2-enriched

Fundamental Combustion Properties of H2/CO Mixtures: Ignition and Flame Propagation at Elevated Pressures