Abstract:Abstract Pelletized magnesium manganese oxide shows promise for high temperature thermochemical energy storage. It can be thermally reduced in the temperature range between 1250 °C and 1500 °C and re-oxidized with air at typical gas-turbine inlet pressures (1–25 bar) in the temperature range between 600 °C and 1500 °C. The combined thermal and chemical volumetric energy density is approximately 2300 MJ/m3. The rate at which a thermochemical storage module can be charged is limited by heat transfer inside the solid packed bed. Hence, the effective thermal conductivity of packed beds of magnesium-manganese oxide pellets is a crucial parameter for engineering Mg-Mn-O redox storage devices. We have measured the effective thermal conductivity of a packed bed of 3.66 ± 0.516 mm sized magnesium manganese oxide (Mn to Mg molar ratio of 1:1) pellets in the temperature range of 300–1400 °C. Since the material is electrically conductive at temperatures above 600 °C, the sheathed transient hot wire method is used for measurements. Raw data is analyzed using the Blackwell solution to extract the bed thermal conductivity. The effective thermal conductivity standard deviation is less than 10% for a minimum of three repeat measurements at each temperature. Experimental results show an increase in the effective thermal conductivity with temperature from 0.50 W/m °C around 300 °C to 1.81 W/m °C close to 1400 °C. We propose a dual porosity model to express the effective thermal conductivity as a function of temperature. This model also considers the effect of radiation within the bed, as this is the dominant heat transfer mode at high temperatures. The proposed model accounts for microscale pellet porosity, macroscale bed porosity, pellet size, solid thermal conductivity (phonon transport), and radiation (photon transport). The coefficient of determination between the proposed model and the experimental results is greater than 0.90.

Experimental Study of MgO/Mg(OH)2 Thermochemical Heat Storage with Direct Heat Transfer Mode

Performance Analysis on Open Thermochemical Sorption Heat Storage from a Real Mass Transfer Perspective

Thermochemical heat storage performance of Fe-doped MgO/Mg(OH) 2 : Experimental and DFT investigation

Kinetics and Structural Optimization of Cobalt-Oxide Honeycomb Structures Based on Thermochemical Heat Storage

Experimental and Simulation Study of Mn–Fe Particles in a Controllable-Flow Particle Solar Receiver for High-Temperature Thermochemical Energy Storage

Numerical Simulation of the Ca(OH)2/CaO Thermochemical Heat Storage Process in an Internal Heating Fixed-Bed Reactor

A Molecular Dynamics Approach and Experimental Validation

Experimental Study on Heat Recovery in a CaO/Ca(OH)2-Based Mechanical Fluidized Bed Thermochemical Energy Storage Reactor

A Simulation Study on the Hydration of Magnesium-Based Thermochemical Heat Storage System for Residential Buildings

Thermophysical Characterization of Magnesium Chloride and Its Application in Open Sorption Thermal Energy Storage System

Experimental and Numerical Studies of Ca(OH)2/CaO Dehydration Process in a Fixed-Bed Reactor for Thermochemical Energy Storage

Investigation on the Initial Stage of the Dehydration Process in Mg(OH) 2 by Density Functional Theory Calculations

Solid–Gas Thermochemical Energy Storage Materials and Reactors for Low to High-Temperature Applications: A Concise Review

Experimental Investigation on Thermochemical Heat Storage Using Ca(OH)2/CaO in the Cyclone Reactor

Experimental investigation of a novel mechanically fluidized bed reactor for thermochemical energy storage with calcium hydroxide/calcium oxide

Ultra-High Temperature Thermal Conductivity Measurements of a Reactive Magnesium Manganese Oxide Porous Bed Using a Transient Hot Wire Method

Design and Performance Verification of a Fast-Reaction Thermogravimetric Analyzer

Experimental investigation of a thermochemical energy storage system based on MgSO 4 -silica gel for building heating: adsorption/desorption performance testing and system optimization

Heat transfer and heat storage characteristics of calcium hydroxide/oxide based on shell-tube thermochemical energy storage device

A Moving Bed Reactor for Thermochemical Energy Storage Based on Metal Oxides

Performance of thermochemical energy storage of a packed bed of calcium hydroxide pellets