Small Satellites SSC 16-IV-3 System-ona-chip based nano star tracker and its real-time image processing approach

Minsong Wei

2016-01-01

Abstract:The star tracker is one of the most accurate components for satellite attitude determination. With the development of the nano star tracker, it is compatible for application on small satellites. However, the drawback in dynamic property of nano star tracker has limited its extensive applications. The principal objective of this study is to introduce a system-on-a-chip (SOC) based nano star tracker with enhanced dynamic property. A morphology based image processing approach was realized based on single FPGA to achieve real-time star extraction, even from a blurred image. Such nano star tracker has been developed and tested, and field experiment results indicated that its dynamic range was up to 4°/s with a data update rate of 30Hz. Moreover, the orientation of the satellite with developed nano star tracker on board has been analyzed based on the telemetry data. Thus, such nano star tracker could promote its applications on small or agile satellites. INTRODUCTION Nowadays, the advantage of small satellites have intrigued rapid development of new technologies or products [1]. Due to the small size and low weight, it is promising to utilize small satellites for remote sensing or optical application where agility control is required. Although star trackers are the most accurate attitude determination sensors, traditional star trackers have the disadvantage of large size, heavy weight, high power consumption and poor dynamic characteristics [2, 3]. Fig. 1 shows three different kinds of star trackers developed by Tsinghua University. The micro star tracker is a traditional star tracker, which has been proven successful for high accuracy with several times of in-flight experience [4]. The electrical structure of micro star tracker is based on FPGA and DSP; FPGA is employed for image capturing and DSP is employed for image processing. In such structure and image processing procedures, a whole image should be stored in SRAM for image processing, resulting in large storage memory. Furthermore, image capturing and image processing are separated, and image processing cannot be executed until a whole image is fully acquired and stored in memory, which leads to a low data update rate (5Hz, as listed in Table 1). (a) (b) (c) Figure 1: Prototypes of different star trackers developed by Tsinghua University (a. micro star tracker without baffle; b. nano star tracker with baffle and c. pico star tracker) Table 1: Properties of micro star tracker Parameter Value Size (with baffle) 100 × 100 × 260mm Mass (with baffle) 1500g Power consumption 1.3W Data update rate 5Hz In this study, a System-on-a-Chip (SOC) based nano star tracker was developed with 50 × 50 × 100mm in size and 245g in weight. To make full use of such SOC based structure, a morphology based image processing approach was implemented by hardware and the data update rate was improved to 30Hz. Field test results indicated that the proposed image method was robust in