Abstract:Hydro turbines operating at partial flow conditions usually have vortex ropes in the draft tube that generate large pressure fluctuations. This unsteady flow phenomenon is harmful to the safe operation of hydropower stations. This paper presents numerical simulations of the internal flow in the draft tube of a Francis turbine with particular emphasis on understanding the unsteady characteristics of the vortex rope structure and the underlying mechanisms for the interactions between the air and the vortices. The pressure fluctuations induced by the vortex rope are alleviated by air admission from the main shaft center, with the water-air two phase flow in the entire flow passage of a model turbine simulated based on the homogeneous flow assumption. The results show that aeration with suitable air flow rate can alleviate the pressure fluctuations in the draft tube, and the mechanism improving the flow stability in the draft tube is due to the change of vortex rope structure and distribution by aeration, i.e. a helical vortex rope at a small aeration volume while a cylindrical vortex rope with a large amount of aeration. The preferable vortex rope distribution can suppress the swirl at the smaller flow rates, and is helpful to alleviate the pressure fluctuation in the draft tube. The analysis based on the vorticity transport equation indicates that the vortex has strong stretching and dilation in the vortex rope evolution. The baroclinic torque term does not play a major role in the vortex evolution most of the time, but will much increase for some specific aeration volumes. The present study also depicts that vortex rope is mainly associated with a pair of spiral vortex stretching and dilation sources, and its swirling flow is alleviated little by the baroclinic torque term, whose effect region is only near the draft tube inlet.

Pressure Oscillations in a Hydraulic Turbine Draft Tube

Pressure pulsation in small opening operating mode of pump turbine’s turbine mode

Study on cavitating vortex rope characteristics of reversible pump-turbine under part load turbine condition

Simulations and Measurements of Pressure Oscillations Caused by Vortex Ropes

Numerical Predictions and Stability Analysis of Cavitating Draft Tube Vortices at High Head in a Model Francis Turbine

Pressure Fluctuations in a Francis Turbine Draft Tube Calculated by Cavitating Flow Simulation

Comparisons of Vortical Flow and Cavitation Inside a Francis Turbine with Different Draft Tubes

Pressure Oscillations with Ultra-Low Frequency Induced by Vortical Flow Inside Francis Turbine Draft Tubes

Numerical Simulation of Pressure Vibrations in a Francis Turbine Draft Tube with Air Admission

Pressure Oscillation Suppression by Air Admission in a Francis Turbine Draft Tube

Unsteady Turbulent Simulation of Prototype Hydraulic Turbine and Analysis of Pressure Fluctuation in Draft Tube

Experimental and Numerical Analysis of Pressure Pulses Characteristics in A Francis Turbine with Partial Load

Simulation of Unsteady Flow Induced by in Vortices the Draft Tube of a Francis Turbine

Numerical Predictions of Pressure Fluctuations in a Model Pump Turbine with Small Guide Vane Opening based on Partial Averaged Navier Stokes Approach

Numerical Analysis of Misaligned Guide Vanes Effect Pressure Oscillations in a Prototype Pump Turbine

Studies Of The Effect Of Vortex-Control Grooves On Pressure Oscillations In A Francis Turbine Draft Tube

Study on the method of reducing the pressure fluctuation of hydraulic turbine by optimizing the draft tube pressure distribution

Unsteady Vortical Flow Simulation in a Francis Turbine with Special Emphasis on Vortex Rope Behavior and Pressure Fluctuation Alleviation

Correlation Analysis of the Internal Vortex Flow of Hydro Turbine with the Pressure Fluctuation Inside Draft Tube

Numerical Study of Pressure Fluctuations in Different Guide Vanes' Opening Angle in Pump Mode of a Pump Turbine

Simulation of dynamic loads on Francis blades at partial load