Abstract:This research aims to increase the utilization of platinum–ruthenium alloy (PtRu) catalysts and thus to lower the catalyst loadings in the electrode for methanol electrooxidation. The electrodeposition of PtRu was performed on a rotating disk electrode (RDE) of glassy carbon (GC), on which a layer of Nafion®-bonded carbon (Vulcan XC 72R) was dispersed in advance. First, the behavior of Pt RDE and GC RDE in an aqueous solution containing HCl, H2PtCl6 and RuCl3 was studied. It was found that the hydrogen evolution becomes a dominant reaction when the electrode potential is below −0.20 V vs. SSCE (saturated-potassium–chloride silver chloride electrode). The hydrogen evolution was strongly enhanced with the formation of nanometer-sized Pt particles on the RDE. To enrich Pt and Ru ions, present in the form of anionic complexes in solution, onto the carbon particles in the uncatalyzed carbon electrode (UCE) and, most importantly, to eliminate the hydrogen bubbles formed on the UCE during the cathodic deposition, a positive current was imposed on the UCE for a period of time prior to each step of cathodic deposition of PtRu, should multiple steps of cathodic deposition be required. Cyclic voltammograms (CVs) of electrodes in 0.5 M H2SO4 before and after deposition were used to evaluate the loading of metal catalysts based upon the profile of CV in a wide range of potentials from −0.20 to 1.1 V vs. SSCE. The catalytic activity of electrodes prepared under different conditions for methanol electrooxidation was studied by electrochemical methods. The results showed that the performance of the electrode (prepared in this study) with loadings estimated to 77 μg PtRu/cm2 is much better than that of a conventional electrode with loadings of 100 μg Pt/cm2. The role of ruthenium in methanol oxidation was also discussed in electrochemical terms.

Electrochemical Impedance Spectroscopy of Methanol Electrooxidation on PtRu/C Catalysts

Effect of Electrochemical Polarization of PtRu/C Catalysts on Methanol Electrooxidation

Highly Stable Pt–Au@Ru/C Catalyst Nanoparticles for Methanol Electro-oxidation

In Situ Electrochemical FTIR Spectroscopy of Adsorption and Oxidation Process of Methanol on PtRu/C Electrocatalyst

Electrochemical impedance studies of electrooxidation of methanol and formic acid on Pt/C catalyst in acid medium

Study on Methanol Oxidation at Pt and PtRu Electrodes by Combining in situ Infrared Spectroscopy and Differential Electrochemical Mass Spectrometry

Negative resistance for methanol electro-oxidation on platinum/carbon (Pt/C) catalyst investigated by an electrochemical impedance spectroscopy

Investigation of methanol electrooxidation on Pt and Pt-Ru in H 3PO 4 using MEA with PBI-H 3PO 4 membrane

Electrochemical Impedance Studies on Carbon Supported PtRuNi and PtRu Anode Catalysts in Acid Medium for Direct Methanol Fuel Cell

Studies on the electrocatalytic properties of PtRu/C-TiO2 toward the oxidation of methanol

Comparative investigation of Pt-Ru/C catalysts on different electrode for methanol electrooxidation

Investigations of compositions and performance of PtRuMo/C ternary catalysts for methanol electrooxidation

Comparison of Methanol Electrooxidation on Carbon Supported Pt and Ptru Catalysts

Comparative Studies of Adsorbed CO and Methanol Electrooxidation on Carbon Supported Pt and PtRu Catalysts in Acid Solution

Electrooxidation Mechanism of Methanol at Pt‐Ru Catalyst Modified GC Electrode in Electrolytes with Different Ph Using Electrochemical and SERS Techniques

Influence of Metal Oxides on Pt Catalysts for Methanol Electrooxidation Using Electrochemical Impedance Spectroscopy

Comparative study of Pt/CeO2-CNTs and PtRu/C as methanol electro-oxidation catalysts

Electrochemical deposition of PtRu on an uncatalyzed carbon electrode for methanol electrooxidation

The Investigation of Electro-Oxidation of Methanol on Pt-Ru Electrode Surfaces by In-Situ Raman Spectroscopy

Changes of Composition and Structure of Pt-Ru/C Catalyst in the Methanol Electro-Oxidation Process

Nonlinear Spectroscopy Analysis for Electrocatalytic Oxidation of Methanol on PtRu/C Surface