Abstract:The thermophysical properties of Ni-based single-crystal superalloys were investigated using first-principles calculations combined with the quasiharmonic approximation. The effect of alloying elements X (X = Re, Ru, Ta, W, Mo, Cr, and Co) on the thermophysical properties of the γ-Ni and γ'-Ni3Al phases was investigated. The calculations showed that alloying can effectively adjust the lattice misfit between the two phases, and Cr can suppress lattice misfit and may improve the creep resistance of alloys. At 0 K, doping with refractory elements leads to tetragonal shear softening of the γ-Ni phase. For γ-Ni, Re, Ru, Cr, and Co slightly increase c44, while Mo, W, and Ta decrease c44. Importantly, high-temperature relative hardening was found to occur close to the service temperature of the superalloy, at which Ru and Cr increase c' and Mo and W increase c44 of γ-Ni. For the γ'-Ni3Al phase, all of the alloying elements except Co considerably increase c' and c44. Re and W at the Al site were found to most effectively harden the γ'-Ni3Al phase. The thermophysical and elastic properties were fully understood by analysis of the electronic structures and phonon spectra. It was found that the electronic density of states (DOS) can account for elastic hardening due to alloying. The phonon spectra along with electronic DOS analysis showed that alloying not only strengthens the first nearest neighbor Ni-X bond through additional d-d hybridization, but it is also important for stiffening the second nearest neighbor Al-X bonding through p-band filling.

Investigation on Anharmonicity, Vibrational Anisotropy and Thermal Expansion of an Amorphous Ni$_{46}$Ti$_{54}$ Alloy Produced by Mechanical Alloying using Extended X-ray Absorption Fine Structure

Modeling the amorphous structure of a mechanically alloyed Ti50Ni25Cu25 alloy using anomalous wide-angle x-ray scattering and reverse Monte Carlo simulations

Thermal Expansion of a Multiphase Intermetallic Ti-Al-Nb-Mo Alloy Studied by High-Energy X-ray Diffraction

The Mechanical Properties of Intermetallic Ni50−xTi50Alx Alloys (X=6,7,8,9)

In-situ Investigation Via High Energy X-ray Diffraction of Stress-Induced(0002)α→(110)β Transformation in a Ti-5.5Mo-7.2Al-4.5Zr-2.6Sn-2.1Cr Alloy

Comparison among the local atomic order of amorphous TM-Ti alloys (TM=Co, Ni, Cu) produced by Mechanical Alloying studied by EXAFS

XPS and NEXAFS Investigation of Electronic Energy Structure of Ti-Ni and TiNi-Cu Alloys

Evolution of local atomic structure in a melt-spun Ni25Ti 50Cu25 shape memory alloy during crystallization

Anomalies in the short-range local environment and atomic diffusion in single crystalline equiatomic CrMnFeCoNi high-entropy alloy

Experimental and molecular dynamics simulation study of structure of liquid and amorphous Ni62Nb38 alloy

Microscopic Structural and Dynamical Properties of Amorphous Metallic Alloy $Ni_{33}Zr_{67}$ at the Temperature $T=300K$

Exafs Measurements and Reverse Monte Carlo Modeling of Atomic Structure in Amorphous Ni80p20 Alloys

Tuning Thermal Expansion by a Continuing Atomic Rearrangement Mechanism in a Multifunctional Titanium Alloy

Density functional theory study of the thermodynamic and elastic properties of Ni-based superalloys

In situ study of non-equilibrium solidification of CoCrFeNi high-entropy alloy and CrFeNi and CoCrNi ternary suballoys

Insights into Elastic and Thermodynamics Properties of Binary Intermetallics in Ni-Al Alloys under Extreme Condition: Full-Electronic Quasi-Harmonic Study

Grain-resolved temperature-dependent anisotropy in hexagonal Ti-7Al revealed by synchrotron X-ray diffraction

Investigation on Vibrational, Optical and Structural Properties of an Amorphous Se$_{0.80}$S$_{0.20}$ Alloy Produced by Mechanical Alloying

Experimental investigation of the local environment and lattice distortion in refractory medium entropy alloys

Atomistic Investigation of Elementary Dislocation Properties Influencing Mechanical Behaviour of $Cr_{15}Fe_{46}Mn_{17}Ni_{22}$ alloy and $Cr_{20}Fe_{70}Ni_{10}$ alloy

High-temperature thermal expansion of binary alloys of Ni with Cr, Mo and Re: a comparison with molecular dynamics simulations