Abstract:Advances in Mechanical Engineering, Volume 14, Issue 12, December 2022. Based on long-term inspection data about track geometric irregularity of 32 m-span simply supported girder bridge in China Railway High-Speed for nearly 10 years, it is found that there is continuous periodic track longitudinal level (TLL) with different wavelengths, thereinto, simply supported girder bridges creep and ballastless track slab upwarp are the primary reasons. Moreover, there are two types of variation trends for bridge creep of 32 m simply-supported bridges with ballastless track, that is, stable type and increasing type, and the maximum [math] (the peak-to-peak value of track longitudinal level) is 7.1 mm for track longitudinal level caused by bridge creep, and the maximum [math] caused by upwarp deformation of ballastless track slab is 3.2 mm. Hence, this paper investigated the effects on running performance and structure service performance of random track irregularity and additional track irregularity caused by bridge creep, track slab upwarp deformation or superposition of both, a three-dimensional finite element model of vehicle-track-bridge for dynamic simulation calculation was established, the threshold values for bridge creep and track slab deformation under 350 km/h were proposed based on running performance and structure service performance. Finally, research results show that bridge creep influences on the ride comfort significantly, but running safety barely. Due to the short wavelength of TLL, the track slab upwarp deformation affects both the ride comfort and running safety heavily. The car bodies are more sensitive to bridge creep and produce mainly low-frequency vibration, but the rate of wheel load reduction is more sensitive to the track deformation and shows the high-frequency vibration. For 32 m simply supported bridges without track slab deformation, the [math] caused by bridge creep should be limited to 7 mm, and 9 mm in difficult situations. When the [math] caused by bridge creep is small (less than 5 mm), the [math] caused by track slab upwarp deformation must be less than 4 mm. When both deformations exist simultaneously, the [math] caused by superposition deformations of both should not exceed 10 mm, with track slab upwarp deformation not exceeding 4 mm. In the presence of both structural deficiencies, it is suggested that the track slab deformation must be eliminated when it is difficult to eliminate the bridge creep.

An Analytical Solution to the Mapping Relationship Between Bridge Structures Vertical Deformation and Rail Deformation of High-Speed Railway

Three-dimensional Finite Element Simulation on Moving Load Induced Track Response over Stiffness-varied Base

Mapping Relation between Rail and Bridge Deformation Considering Nonlinear Contact of Interlayer

Lateral girder displacement effect on the safety and comfortability of the high-speed rail train operation

Analysis approach and reliability analysis of cumulative cyclic deformation of subgrade of single high-speed railway line

Assessment and prediction of high speed railway bridge long-term deformation based on track geometry inspection big data

Technical Note: Three-dimensional analyses of dynamic responses of track-ground system subjected to a moving train load

Study on the Stiffness and Dynamic Characteristics of a Bridge Approach Zone: Tests and Numerical Analyses

A Theoretical Investigation on Influences of Slab Tracks on Vertical Dynamic Responses of Railway Viaducts

Creep Effect on the Dynamic Response of Train-Track-Continuous Bridge System

Simplified linear analysis model of longitudinal constraint effect of high-speed railway simply-supported bridge under frequent earthquake

On stress and deformation accumulation of continuously welded rails under cyclic thermal loading in high-speed railways

Impact of vertical girder deformations on the high-speed train operation performance

Analytical study on geometrical irregularity and internal loads of railways with CRTS I ballastless tracks on arch bridges subject to thermal effects

Refined dynamic analysis of three slab tracks on bridge structures under various high-speed train loads

Study on the threshold for superposed deformation of simply supported bridge creep and track slab upwarp in high-speed railway

Study on the influence of damage characteristics of longitudinal ballastless track on the dynamic performance of train-track-bridge coupled systems

Mechanical deformation Properties of Continuous Welded Rail on Kilometer-Span Suspension Bridge for High-speed Railway

A Novel Model for Train–Track-Bridge Dynamic Interaction Considering Non-Uniform Structural Parameters and Nonlinear Interlayer Contact

Interaction Dynamic Response of a High-Speed Train Moving Over Curved Bridges with Deficient or Surplus Superelevation

Mechanical Performance of a Ballastless Track System for the Railway Bridges of High-Speed Lines: Experimental and Numerical Study under Thermal Loading