Anaerobic Co-digestion of Urban Sewage Sludge with Agricultural Biomass

Li Pengfei,He Chao,Yu Ran,Shen Dekui,Jiao Youzhou

DOI: https://doi.org/10.1007/s12649-019-00870-z

2019-01-01

Waste and Biomass Valorization

Abstract:Three different types of urban sewage sludges (the mixed sludge, the dewatered secondary sludge and the sludge filtered by screens) were used for individual anaerobic digestion and co-digestion with agricultural biomass. The initial TS level (4%) and substrate to inoculum ratio (3:1) were maintained into all runs at mesophilic conditions, and the co-substrates was mixed at the recommended VS ratio of 1:1 (sludge: straw under the co-digestion conditions. It was found that the mixed sludge exhibited prominent anaerobic digestion performance, selected as a potential reagent for the co-digestion with biomass. The total volume of the produced methane from co-digestion of the mixed sludge and wheat stalk reached to 187.01 ± 3.27 mL g−1 VSadded, which was about 1.52 times higher than that from the individual digestion of the sludge. The experimental value of methane yield from co-digestion of the mixed sludge with wheat stalk is about 9.46% more than that of the estimated value, imply the enhanced interactions between the sludge and biomass during the co-digestion process. The pH of the co-digestion system of the mixed sludge and the wheat stalk was maintained at a relevant stable value around 6.50. It indicated that the buffering capacity of the digestion system could improved by adding the mixed sludge. The modified Gompertz model and the first-order kinetic model were proposed to simulate the co-digestion process between the mixed sludge and agricultural straw. The estimated kinetic parameters indicated that the maximum releasing rate of methane was significantly increased during the co-digestion process.