Abstract:Fermentative hydrogen production from waste activated sludge (WAS) has low H2 yield because WAS contains limited amounts of carbohydrate suitable for use by hydrogen-producing bacteria. Here, augmentation of hydrogen production from WAS by microbial electrolysis cells (MECs) was implemented. H2 yields of 3.89±0.39 mg-H2/g-DS (5.67±0.61 mg-H2/g-VSS) from raw WAS and 6.78±0.94 mg-H2/g-DS (15.08±1.41 mg-H2/g-VSS) from alkaline-pretreated WAS were obtained in the two-chamber MECs (TMECs). This was several times higher than yields obtained previously by fermentation. Single-chamber MECs (SMECs) with low internal resistance showed a H2 production rate that 13 times that of TMECs with similar H2 yield when alkaline-pretreated WAS was used. However, methanogenesis was detected after several batch cycles. A yield balance calculation revealed that carbohydrates were not the only substrates for electrohydrogenesis. Protein and its acidification products, such as volatile fatty acids are also responsible for a portion of H2 generation in MEC. Characterization of WAS in TMECs by three-dimensional excitation-emission matrix (EEM) fluorescence spectroscopy with parallel factor analysis indicated that electrohydrogenesis reacted on the extracellular polymeric substances and intracellular substances of WAS. Cascade utilization of organic matter in MECs increased hydrogen production from WAS. MECs showed high hydrogen yield from WAS, fewer H2 sinks, and insensitivity to temperature. Optimizing MEC configurations and operation conditions and improving the pretreatment processes of WAS are necessary before practical application can take place on a large scale.

Continuous Hydrogen Production from Food Waste by Anaerobic Digestion (AD) Coupled Single-Chamber Microbial Electrolysis Cell (MEC) under Negative Pressure

Effect of Ammonia Concentration on Hythane (H2 and CH4) Production in Two-Phase Anaerobic Digestion

An effective method for hydrogen production in a single-chamber microbial electrolysis by negative pressure control

Continuous co-generation of biohydrogen and biomethane through two-stage anaerobic digestion of hydrothermally pretreated food waste

Simultaneous biohythane and volatile fatty acids production from food waste in microbial electrolysis cell-assisted acidogenic reactor

Evaluation of a mixture of livestock wastewater and food waste as a substrate in a continuous-flow microbial electrolysis cell

Hydrogen Production by the Thermophilic Dry Anaerobic Co-Fermentation of Food Waste Utilizing Garden Waste or Kitchen Waste as Co-Substrate

Efficient hydrogen production from food waste leachate using single-chamber microbial electrolysis cell

Enhanced hydrogen production from waste activated sludge by cascade utilization of organic matter in microbial electrolysis cells

Methane Production from Food Waste Via Mesophilic Anaerobic Digestion with Ethanol Pre-Fermentation: Methanogenic Pathway and Microbial Community Analyses.

Improved net energy recovery in a sludge anaerobic digestion process by coupling an electrochemical system: electrode material and its impact on suspended microbial community

An MEC-MFC-Coupled System for Biohydrogen Production from Acetate

Pilot microbial electrolysis cell closes the hydrogen loop for hydrothermal wet waste conversion to jet fuel

Hydrogen production in a microbial electrolysis cell fed with a dark fermentation effluent

Enhancement of Anaerobic Methanogenesis at A Short Hydraulic Retention Time Via Bioelectrochemical Enrichment of Hydrogenotrophic Methanogens

Environmental impact assessment of a combined bioprocess for hydrogen production from food waste

Optimization of Simultaneous Production of Volatile Fatty Acids and Bio-Hydrogen from Food Waste Using Response Surface Methodology

Electricity Generation from Mixed Volatile Fatty Acids Using Microbial Fuel Cells.

Microbial electrolysis cells for high yield hydrogen gas production from organic matter.

Enhancement of methane production from waste activated sludge using hybrid microbial electrolysis cells-anaerobic digestion (MEC-AD) process – A review

A review on the applications of microbial electrolysis cells in anaerobic digestion