Abstract:Ethanol has great application prospects given it is an important essential chemical and a substitute for traditional energy sources. Currently, ethanol production is achieved through grain fermentation and petroleum-based ethylene hydration. However, the inefficient fermentation processes and increasingly depleted crude oil resources hinder the large-scale production of ethanol. Therefore, the development of alternative technologies for ethanol production has become an important issue. The direct production of ethanol from syngas (CO + H-2) is considered to be a new strategy to acquire high value-added products and achieve clean utilization of carbonaceous resources such as coal, natural gas, and biomass. Supported Rh-based catalysts have been extensively studied as the most promising and effective systems for the direct production of ethanol from syngas. The use of promoters and supports is generally effective in increasing the activity and ethanol selectivity of supported Rh-based catalysts. Fe is widely used in the research on Rh-based catalysts, as it is one of the most effective promoters for enhancing ethanol selectivity. In this work, with the aim of exploring the role of the support, we used the incipient wetness impregnation method to prepare Fe-promoted Rh-based catalysts supported by CeO2, ZrO2, and TiO2 for the synthesis of ethanol from syngas. CO conversion of CO on the RhFe/TiO2 catalyst was as high as 18.2% under the reaction conditions of 250 degrees C and 2 MPa, and the selectivity to ethanol in the alcohol distribution was 74.7%, which was much higher than that observed with RhFe/CeO2 and RhFe/ZrO2 under the same conditions. The characterization results showed that the specific surface of the catalyst followed the order RhFe/CeO2 < RhFe/ZrO2 < RhFe/TiO2; the dispersion of Rh increased sequentially, and the particle size decreased in the same order. A larger specific surface area may favor the dispersion of the Rh species, and the highly dispersed Rh species would imply a greater number of active sites on the surface of the support. The results of H-2-temperature-programmed reduction indicated possible interactions between Rh and the support as well as between Rh and Fe, and partial reduction of TiO2 under the experimental reduction conditions; however, the other supports did not undergo reduction. The results of X-ray photoelectron spectroscopy indicated that the RhFe/TiO2 catalyst had the largest amount of Rh-0 as well as Rh+ species. Thus, this catalyst has more (Rh-x(0)-Rh-y(+))-O-Fe delta+ active sites for the synthesis of ethanol, which greatly increases the ethanol selectivity. CO-temperature programmed desorption was used to confirm the CO adsorption capacity of different catalysts. The results showed that TiO2 enhances the adsorption of CO due to the presence of more O vacancies and Ti3+ ions, which is beneficial to the improvement of the catalyst activity.

Active Sites in CO2 Hydrogenation over Confined VOx-Rh Catalysts

Enhanced CH4 Production from CO2 Hydrogenation on Γ-Alooh-supported Cobalt Catalyst with Abundant Surface Coordination Unsaturated Oxygen Atoms

STUDY OF Rh-Sm-V-Li/SiO2 CATALYST FOR CO HYDROGENATION REACTION TO C2-OXYGENATES

Dual active sites over Cu-ZnO-ZrO2 catalysts for carbon dioxide hydrogenation to methanol

Grain Boundaries Modulating Active Sites in RhCo Porous Nanospheres for Efficient CO2 Hydrogenation

INFLUENCE OF VOCl_2- ADDITIVE IN Rh CATALYST ON CO HYDROGENATION

The Effects of PVP-modified SiO2 on the Catalytic Performance of CO Hydrogenation over Rh-Mn-Li/SiO2 Catalysts

Active Sites for CO2 Hydrogenation to Methanol: Mechanistic Insights and Reaction Control

CO2 hydrogenation to methanol over Rh/In2O3 catalyst

Nature of the Active Sites of VOx/Al2O3 Catalysts for Propane Dehydrogenation

CO Hydrogenation to Ethanol over Supported Rh-Based Catalyst: Effect of the Support

P-modi fi ed SiO 2 on the catalytic performance of CO hydrogenation over Rh – Mn – Li / SiO 2 catalysts

Ga-Promoted CuCo-Based Catalysts for Efficient CO2 Hydrogenation to Ethanol: the Key Synergistic Role of Cu-CoGaOx Interfacial Sites.

Highly Selective Conversion of COx to C2-4 Hydrocarbons over MoSx@HSSZ-39 Catalyst

Understanding the Active-Site Nature of Vanadia-Based Catalysts for Oxidative Dehydrogenation of Ethylbenzene with CO2 Via Atomic Layer Deposited VOx on Γ-Al2o3

Ethanol Synthesis from Syngas on Mn- and Fe-promoted Rh/γ-Al2O3

Selective Hydrogenation of CO2 to Ethanol over Cobalt Catalysts

Tandem Catalysis for Hydrogenation of CO and CO2 to Lower Olefins with Bifunctional Catalysts Composed of Spinel Oxide and SAPO-34

COx hydrogenation to methanol and other hydrocarbons under mild conditions with Mo3S4@ZSM-5

The Synergetic Effect of Dual Active Sites in ZnO-ZrO 2 Catalyst for CO 2 Hydrogenation to Methanol

Vanadium oxide supported on mesoporous MCM-41 as new catalysts for dehydrogenation of ethylbenzene with CO2