Abstract:A novel technology for flue gas pre-treatment in the phase transition process is proposed in this paper to better remove the fine particles and trace elements from coal-fired power plants. Wet removal, Brownian diffusion, diffusiophoresis, thermophoresis and disturbed pipe flow occurring in the phase transition process were taken into consideration during the development of the technology. An item of equipment called a wet phase transition agglomerator (WPTA) was developed based on the aforementioned technology. The WPTA and the wet electrostatic precipitator (WESP) constituted a wet dust removal system (WDRS), which was used at a 660 MW ultra-supercritical unit in China as a demonstration project. The particles at the inlet and outlet of the WDRS, as well as the wastewater from the system, were sampled to investigate the performance of the WDRS. The results indicate that the WDRS helps to bring about ultra low emissions of particles from the coal-fired power plant, keeping the level of particle emission below 5 mg/m(3) under all measurement conditions. It was found that the collection efficiency of the WESP increased significantly with an increasing applied voltage. The performance of the WDRS can be further improved by the WPTA, for the removal efficiency of total suspended particulates at boiler operating loads of 90% and 75% rose 4.01 and 3.17 percentage points, respectively. Moreover, the removal efficiency of PM1 increased from 68.67% to 83.61% with the WPTA running at a load of 90%. The TEs removal was also found to be enhanced by the WPTA. The masses of Hg, As and Mn carried by the wastewater per hour with the WPTA running increased 4.2, 2.8 and 1.5 times, respectively, over values when the WPTA was turned off. (C) 2017 Published by Elsevier Ltd.

Study on the Coagulation of Vapor Condensates and Fine Particulates in a Phase-change Agglomerator

Investigation on Fine Particulate Matters Removal by Using Wet Phase Transition Agglomeration Technology Cooperated With Wet Electro Static Precipitator

Investigation on Removal Effects and Condensation Characteristics of Condensable Particulate Matter: Field Test and Experimental Study.

Development of Wet Phase Transition Agglomerator for Multi-Pollutant Synergistic Removal

ICOPE-15-C071 the Study on Agglomeration and Removal of Fine Particles in Wet Phase Transition Condensation Process

Study on characteristics of organic components in condensable particulate matter before and after wet flue gas desulfurization system of coal-fired power plants

Experimental Study on the Synergetic Removal of Fine Particles by Wet Flue Gas Desulfurization Tower with a Flow Pattern Control Device

Promoting fine particle removal in double-tower cascade wet flue gas desulfurization system by flue gas temperature reduction

The Research and the Engineering Demonstration of Particles Agglomeration in Phase Transition Process Improving the Collection Efficiency of WESP

Improving the removal of particles and trace elements from coal-fired power plants by combining a wet phase transition agglomerator with wet electrostatic precipitator

Enhancing fine particle separation by hybrid-electrostatic-turbulence coagulation: An experimental and numerical investigation

Co-Benefits of Pollutant Removal, Water, and Heat Recovery from Flue Gas through Phase Transition Enhanced by Corona Discharge

Industrial application and numerical simulation on discrete dynamics of fine particulate matters: Condensational growth, deposition and agglomeration

Study on the Control of Condensable Particulate Matter by Spraying Activated Carbon Combined with Electrostatic Precipitator

Experimental Study on Removal Effect of Wet Flue Gas Desulfurization System on Fine Particles from a Coal-fired Power Plant

Spraying coupled with turbulence mechanisms enhanced the removal of fine particles in wet flue gas

Experimental Study on Humidification Coagulation and Removal of Fine Particles Using an Electrostatic Precipitator

Development and Industrial Application of Wet Phase Transition Agglomerator for Water Recovery and Synergistic Removal of Multiple Pollutants from Flue Gas

Synergistic Humidification and Chemical Agglomeration to Improve Capturing the Fine Particulate Matter by Electrostatic Precipitator

Experimental Study on Emission Characteristics of Particulate Matters from Wet Flue Gas Desulfurization System of a Coal-fired Power Plant

An assessment of inorganic components in condensable particulate matter as a function of surface aggregation, spatial suspension state and particle size