Abstract:Microwave drying is a rapid, high-effect, and economical method to decrease the moisture content of biomass materials to produce higher quantity and better quality bio-oil during the fast pyrolysis process. In this paper, the influence of microwave drying on the behavior of biomass pyrolysis was investigated in a bench-scale fluidized-bed reactor in comparison to drying in an electrical oven at 105 degrees C. Three types of biomass were studied, comprising pine wood sawdust, peanut shell, and maize stalk. First, biomass samples were dried using a microwave oven at four different power levels, i.e., 200, 400, 600, and 800 W. It was found that the power capacity of the microwave showed great influence on the moisture removing property. The dehydration was very fast, and it was finished in 6 min at 600 W; however, it was quite slow with electrical oven drying (about 40 min). The specific surface area of biomass was found, being increased greatly after microwave drying. Then, the pyrolysis of biomass samples dried by two different methods was carried out in the bench-scale reactor at 500 degrees C. Samples dried at 600 W in 6 min were selected as representative for microwave drying. The yields and properties of pyrolysis products, including liquid oil, solid char, and uncondensable gas, were determined and analyzed. It was observed that the yields of solid char and liquid oil increased, while the yield of the gas product decreased by microwave oven drying compared to conventional electrical oven drying. A higher CO2 concentration in gas but a lower organic compound content in char was achieved using microwave drying. At the same time, the viscosity and heating value increased because the water content decreased and the average molecular weight increased in the bio-oil from the samples dried by the microwave. These results were all caused by the fact that microwave drying suppressed the second reaction of volatiles during biomass pyrolysis. A higher heating value and lower water content are beneficial to bio-oil use as a fuel, and more primary pyrolysis products make bio-oil produce high add-value chemical materials. Thus, microwave drying is a technically and economically feasible pretreatment method for biomass fast pyrolysis.

Effects of Microwave Pretreatment on Catalytic Fast Pyrolysis of Pine Sawdust.

Kinetics study on microwave-assisted catalytic decomposition of phenylethyl phenyl ether

Influence of Torrefaction with Microwave and Furnace Heating on Pyrolysis of Poplar Sawdust

Properties of gas and char from microwave pyrolysis of pine sawdust

Microwave Pretreatment Power and Duration Time Effects on the Catalytic Pyrolysis Behaviors and Kinetics of Water Hyacinth

Microwave Drying of Biomass and Its Effect on Pyrolysis Characteristics

Catalytic fast pyrolysis of bamboo pretreated by microwave using modified HZSM-5 catalyst

Thermal pretreatment of poplar sawdust at 100 °C in water or with microwave heating impacts the pyrolysis behaviors

Microwave-assisted Acid Pretreatment of Alkali Lignin: Effect on Characteristics and Pyrolysis Behavior.

Analytical Pyrolysis of Pinus radiata and Eucalyptus globulus: Effects of Microwave Pretreatment on Pyrolytic Vapours Composition

Varied Directions of Heat Flow and Emission of Volatiles Impact Evolution of Products in Pyrolysis of Wet and Dry Pine Needles

Microwave-assisted catalytic pyrolysis of lignocellulosic biomass for production of phenolic-rich bio-oil

Fast Pyrolysis Product Distribution of Biopretreated Corn Stalk by Methanogen.

Enhancement of biomass conversion in catalytic fast pyrolysis by microwave-assisted formic acid pretreatment.

Properties and pyrolysis behavior of moso bamboo sawdust after microwave-assisted acid pretreatment

Effect of Torrefaction Temperature on Lignin Macromolecule and Product Distribution from HZSM-5 Catalytic Pyrolysis

The Influence of Microwave Drying on Biomass Pyrolysis

Effect of Torrefaction Pretreatment on the Fast Pyrolysis Behavior of Biomass: Product Distribution and Kinetic Analysis on Spruce-Pin-fir Sawdust

Catalytic effects of eight inorganic additives on pyrolysis of pine wood sawdust by microwave heating

Effect of microwave pretreatment on pyrolysis of chili straw: thermodynamics, activation energy, and solid reaction mechanism

Microwave-assisted pyrolysis of pine wood waste: system development, biofuels production, and characterization