Abstract:Corrugated cardboard is widely used in underground logistic transportation and warehousing and it has become an important fire hazard source. According to previous warehouse fire studies, upward flame spread on corrugated cardboard plays an important role during the initial stage of warehouse fires and can decide the occurrence of subsequent increasing fire hazards. However, the wavy structural effect of corrugated cardboard on fire spread still lacks enough attention. This work studies the fire spread behavior of vertically-set corrugated cardboard with thicknesses of 1.5 mm, 3.0 mm and 4.0 mm. The cardboard inner hollow gaps are set either parallel (defined as along grain direction) or perpendicular (defined as across grain direction) to buoyancy direction. Experimental results show that: (1) along grain sample has better flammability than across grain sample; (2) the relationship between flame height (or pyrolysis height) and time has a best fit with power law, and the difference of the exponents between two grain orientations decreases with the increasing of the sample thickness; (3) for cardboard of different grain orientations and thickness, the ratio of average flame height to average pyrolysis height is a constant. The hollow gaps inside along grain sample, working as passage, are beneficial for the transportation of heated pyrolysis gases and preheating of upper virgin area, hence increasing burning rate and flame upward spread. However, it is observed that the phenomenon (flame luminance, delamination of front layer, extinguishment of flame base, etc.) difference between different grain orientations decreases as sample thickness increases. This study reveals the effects of grain orientation and sample thickness on the corrugated cardboard fire spread behavior which is common in commodity fire in underground logistic transportation and warehousing. The conclusions are beneficial for fire risk assessment as well as the improvement of related codes and regulations.

Experimental study on the burning behavior and combustion toxicity of corrugated cartons under varying sub-atmospheric pressure.

Experimental Study On The Burning Behavior Of Cardboard Box Fire Under Low Air Pressure

Experiment Study Of Cardboard Box Fire Behavior Under Dynamic Pressure In An Altitude Chamber

Solid Fuel Fire Behavior Under Fixed Pressure In A Low-Pressure Chamber

Investigation of the Effect of Low Pressure on Fire Hazard in Cargo Compartment

An experimental study on upward flame spread over corrugated cardboard used in underground logistic transportation: Influence of grain orientation and thickness

EXPERIMENTAL STUDY OF FIRE BEHAVIOR IN A DEPRESSURIZED AIRCRAFT CARGO COMPARTMENT

Influence of Depressurized Environment on the Fire Behaviour in a Dynamic Pressure Cabin

Effect of Pressure and Stacking Method on Combustion Characteristics of Paper Stacks

Study of the influence of low air pressures on fire behavior and burn-through of aircraft cargo liner

Experimental study of large-scale fire behavior under low pressure at high altitude

Experimental Study on the Transitional Behavior of the Room Fire under Sub-Atmospheric Pressures

Controlling Effect Of Oxygen Concentration On Fire Behavior In Low Air Pressure Cargo Compartment

A New Approach Based on the Modified FDS to Numerically Simulate Cardboard Box Combustion under Low Pressure

An Experimental Study of Fire Development under Varying Ventilation Conditions During the Depressurization Process in Pressurized Buildings

Effects of static pressure, pressurization, and depressurization on n-heptane pool fires in an airplane cargo compartment

Investigation on the CO Concentration Decay Profile and Spread Velocity of a Ceiling Jet at Reduced Pressure in Aircraft Cargo Compartment Fires

Flame behavior and fire-induced flow field characteristic in building corridor fire with longitudinal partition

Experimental studies of the effect of burner location on the development of building fires

CO Concentration Decay Profile and Ceiling Jet Entrainment in Aircraft Cargo Compartment Fires at Reduced Pressures

Experimental study on combustion characteristics of fire in data room