Abstract:The rheological properties of warm-mix recycled asphalt binders are critical to enhancing design quality and interpreting the performance mechanisms of the corresponding mixtures. This study investigated the rheological behavior of warm-mix recycled asphalt binders with high percentages of RAP binder. The effects of two warm-mix additives [wax-based Sasobit (S) and surfactant-based Evotherm-M1 (E)], a rejuvenating aging [ZGSB (Z)], four RAP binder contents (0%, 30%, 50% and 70%), and three aging states (unaged, short-term aged and long-term aged) were evaluated in detail using the dynamic shear rheometer (DSR), bending beam rheometer (BBR) and Brookfield rotational viscometer tests as well as conventional performance tests over the whole range of temperatures. The results showed that the rejuvenating agent Z effectively alleviated the aging effect of the RAP binder; however, it could hardly eliminate entirely this negative impact, especially at higher RAP binder contents. The addition of S remarkably lowered the apparent viscosity of the warm-mix recycled binders by up to 35.0%, whereas E had little influence on the binder viscosity due to its surfactant nature. Besides, S performed much better in improving rutting resistance (with the increase of up to 411.3% in |G*|/sinδ) than E, while E exhibited superior fatigue performance (with the reduction of up to 42.3% in |G*|·sinδ) to that of S. In terms of the thermal cracking resistance, E had very slight influence and S even yielded an adverse impact (with the increase of up to 70.2% in Sa and the decrease of up to 34.1% in m-value). Further, S broadened the ranges of pavement service temperatures by about 12 °C, whereas E almost did not change the PG grades of the binders. Finally, regarding the characteristics of viscoelastic master curves, S considerably improved the dynamic modulus and lowered the phase angle of the binders over a wide range of frequencies and temperatures but led to the failure of the time-temperature superposition principle due to its thermorheologically complex nature. Nevertheless, in this regard, the effect of E was found very mild.

Sustainable Utilization of Recycled Waste in High-Viscosity Asphalt Binders: Case for Improvement in Aging Resistance

Research on High- and Low-Temperature Rheological Properties of High-Viscosity Modified Asphalt Binder

Evaluation of Rheological and Aging Behavior of Modified Asphalt Based on Activation Energy of Viscous Flow

Effects of warm-mix asphalt technologies and modifiers on pavement performance of recycled asphalt binders

Chemical and Rheological Evaluation of the Ageing Behaviour of High-Content Crumb Rubber Asphalt Binder

Investigation into Rheological Behavior of Warm-Mix Recycled Asphalt Binders with High Percentages of RAP Binder

Effect of re-aging on chemical and rheological properties of waste engine oil rejuvenated asphalt binder

Improving Asphalt Binder Durability Using Sustainable Materials: A Rheological and Chemical Analysis of Polymer-, Rubber-, and Epoxy-Modified Asphalt Binders

Rheological properties of bituminous binder modified with recycled waste toner

Properties of waste vegetable oil recycled asphalt-binder: a molecular simulation study

Study on the microscopic characteristics and rheological properties of thermal-oxidative aged and virgin-old recycled asphalts

Linear viscoelastic, viscoplastic, and damage characterization of recycled asphalt binders and mixtures containing recycling agents with long-term aging

A molecular dynamics simulation study on the recovery performance of aged asphalt binder by waste vegetable oil rejuvenators

Enhancing Pavement Durability: Comparative Rheological Evaluation of Conventional and Rejuvenated Reclaimed Binders under Aging Conditions

Evaluation of Rheological and Microscopic Properties of SBS-Modified Asphalt Binder with Multiple Regeneration

Recycled Polyethylene and Crumb Rubber Composites Modified Asphalt with Improved Aging Resistance and Thermal Stability

Effect of Polymer and Oil Modification on the Aging Susceptibility of Asphalt Binders

Rheological and Aging Behaviors of Liquid Rubber Modified Asphalt Binders

Laboratory investigation on the properties of warm mixing-recycled asphalt containing waste oil and plastics

High-temperature rheological behavior and fatigue performance of lignin modified asphalt binder

Effects of Waste Polyethylene on the Rheological Properties of Asphalt Binder