Abstract:Summary International regulations have compelled Europe and the United States to phase out certain traditional surfactants to mitigate the use of toxic and nonbiodegradable chemicals. Sodium cocoyl propionate (SCA), as a natural surfactant with high performance, has been proved to have the potential to replace traditional surfactants in previous studies. However, its performance has not fully met practical application requirements. Therefore, in this paper, molecular dynamics (MD) simulation was used to study the detachment behavior and mechanism of SCA, lauryl dimethylamine oxide (OA-12), emulsifier OP-10, and SOO (combination of SCA, OA-12, and OP-10) on crude oil (dodecane, C12) at different temperatures (80–120°C) and salinities (20 000–200 000 mg/L). The complex interaction mechanism between surfactant molecules and C12 molecules was revealed by analyzing the simulated snapshot, radial distribution function (RDF), mean square displacement (MSD), and interaction energy. The simulated snapshot captures the conformational evolution of surfactant molecules at different time points, emphasizing the spatiotemporal and spatial changes of their dynamic behavior. A comparison of two desorption modes reveals that dispersive adsorption displacement and concentrated adsorption displacement are two possible desorption mechanisms. RDF analysis shows that the probability of SOO molecules near C12 remains high even at high-salinity and -temperature conditions. MSD analysis showed that the diffusion capacity of SOO was the highest at 100°C, reaching 1.52867×10 –5 cm2/ps. The calculation of interaction energy results reveals that SOO has a strong adsorption capacity for C12, which is mainly due to the effect of van der Waals (vdW) force. This is because the C12 molecules are inert, and their molecular movement is mainly determined by the polar groups of the surfactant. The main contribution of this study is to provide a natural surfactant with superior performance as a viable alternative, offering experimental settings for further improvement in SCA performance. This research provides theoretical guidance for on-site applications of SCA and SOO to enhance oil recovery.

Aggregation Behaviors of SDBSs at Oil/water Interface: Theoretical and Experimental Study

Evolution of oil/water interface in the presence of SDBS detected by dual polarization interferometry

Molecular dynamics study of the effect of inorganic salts on the monolayer of four surfactants at the oil/water interface

Insights into Zwitterionic Surfactant Interactions at the Oil-Water Interface by Interferometry Experiments and MDS Calculations

Molecular Dynamics Simulation of the Adsorption of Sodium Dodecyl Benzene Sulfonate at the Decane-Water Interface

Impact of Sodium Dodecyl Benzene Sulfonate Concentration on the Stability of the Crude Oil–Mineral Water Interfacial Film: A Molecular Dynamics Simulation Study

Adsorption behavior of oil-displacing surfactant at oil/water interface: Molecular simulation and experimental

Experimental and Molecular Dynamics Studies

Mesoscopic Simulation Study On The Aggregation Behavior Between Lauryl Alcohol Polyoxyethylene And Sodium Lauryl Sulfate

Real-time and Quantitative Investigation of Zwitterionic Surfactant Interaction at Oil-Water Interface: Interferometry Experimental and MD Simulation Insights

Molecular Dynamics Simulation of the Effects of Complex Surfactants on Oil-Water Interaction and Aggregation Characteristics at the Interface.

Study of the Interfacial Array Behaviour of Surfactant at Very Low Concentration by Second Harmonic Generation and Molecular Dynamic Simulation

Oil Detachment Mechanism in Natural Surfactant Flooding from Silica Surface: Molecular Dynamics Simulation

Molecular Mechanisms of Suppressing Asphaltene Aggregation and Flocculation by Dodecylbenzenesulfonic Acid Probed by Molecular Dynamics Simulations

On the synergistic effect of asphaltene and surfactant to reduce n-dodecane–water interfacial tension: insights from molecular dynamics simulations

Influence of Inorganic Salt Additives on the Surface Tension of Sodium Dodecylbenzene Sulfonate Solution

[Coagulation Characteristics of Surfactant SDBS Micellar Solution with Aluminum Salt].

Effect of molecular structure on synergism in mixed zwitterionic/anionic surfactant system: An experimental and simulation study

Molecular Simulation and Experimental Studies on the Interfacial Properties of a Mixed Surfactant SDS/C(4)mimBr

Molecular Dynamics Study on Performance of Olefin Sulfonate at the Decane–Water Interface: Effect of Molecular Architecture