Enhanced Catalytic Performance for Oxygen Reduction Reaction Derived from Nitrogen-Rich Tetrazolate-Based Heterometallic Metal–Organic Frameworks

Li-Qian Ji,Jing Yang,Zi-You Zhang,Yong Qian,Zhi Su,Min Han,Hong-Ke Liu
DOI: https://doi.org/10.1021/acs.cgd.9b00190
IF: 4.01
2019-01-01
Crystal Growth & Design
Abstract:Efficient non-noble metal catalysts for oxygen reduction reaction (ORR) have been highly attractive for the fabrication of cost-effective fuel cells. Metal-organic frameworks (MOFs) derived heteroatom-doped carbon-based (NC) electrocatalysts have exhibited comparable electrocatalytic activity for ORR as commercial Pt/C catalyst, which were highly dependent on their MOF precursor/template structures. In this particular work, two NC composites, NC-1100 and MnO@NC-1100 (NC, nitrogen-doped carbon), have been successfully synthesized, which were derived from novel nitrogen-rich tetrazolate-based metal-organic frameworks, [Cd-2(L)(OH)(H2O)] (1) and [Cd3Mn(L)(2)(OH)(2)(H2O)(2)] (2) (L, 5'-(4-(1H-tetrazol-5-y1)(benzamido)benzene-1,3-dioic acid), respectively. The structural differences between complexes 1 and 2 arose from the introduction of Mn(II) to complex 2, where the Cd(II) in 1 was partially replaced by Mn(II). Both complexes 1 and 2 possessed three-dimensional (3D) structures with one-dimensional (1D) open channels. The resultant MnO@NC-1100 from the pyrolysis of complex 2 at 1100 degrees C under Ar atmosphere has indicated much better electrocatalystic behavior for ORR over the NC-1100 from complex 1, due to the existence of additional active sites of cubic phase MnO particles. The presence of initial Cd(II) benefits the spatial isolation of Mn(II) and prevents the sintering of MnO during the pyrolysis for MnO@NC-1100. The evaporation of Cd(II) and the explosion of nitrogen-rich tetrazolate groups would also promote the surface area of the resulting catalysts. Our study further demonstrated that the multiple metal centers of MOF could be the rational strategy to enhance the electrocatalytical performance. Compared with NC-1100, MnO@NC-1100 exhibited the enhanced electrocatalytic activity with an onset potential (E-onset) of 0.90 V and a half-wave potential (Ehalf-wave) of 0.74 V, which provided an insight view of the structure property relationship.
What problem does this paper attempt to address?