Abstract:Hypothesis: Bacillariophyceae (i.e., diatoms) are an important class of algae with potential use in the production of proteins and lipids including long-chain ω-3 polyunsaturated fatty acids. Biphasic extraction of microalgae lipids using water-immiscible solvents such as hexane, can avoid the excessive energy required to distil solvents from water, but generally requires energy-intensive rupture of the cells. The unique cell structure and surface chemistry of diatoms compared to other microalgae species might allow biphasic lipid extraction without prior cell rupture. Experiments: The kinetics of biphasic lipid extraction from intact Navicula sp. cells was investigated during low-shear and high-shear mixing, and with prior or simultaneous application of ultrasound (20 kHz at 0.57 W/mL). Dynamic interfacial tension measurements and electron microscopic analysis were used to investigate lipid extraction in relation to interfacial behaviour and cell structure. Results: High yields (>80%) of intracellular lipids were extracted from intact cells over the course of hours upon low-shear contacting with hexane. The cells associated with and stabilised the hexane-water interface, allowing hexane to infiltrate pores in the frustule component of the cell walls and access the intracellular lipids. It was shown that mucilaginous extracellular polymeric substances (EPS) bound to the cell walls acted as a barrier to solvent penetration into the cells. This EPS could be removed by prior ultrasonication. Biphasic extraction was greatly accelerated by shear applied by rotor-stator mixing or ultrasound. High-shear could remove mucilaginous EPS from the cell surfaces to facilitate direct contact of the cell surface with hexane and produced smaller emulsion droplets with increased surface area. The combination of high-shear in the presence of hexane resulted in the in-situ rupture of the cells, which greatly accelerated lipid extraction and allowed high yields of neutral lipid (>95%) to be recovered from freshly harvested cells within less than 5 min. The study demonstrated the ability of shear to enable simultaneous cell rupture and lipid extraction from a diatom alga based on its cell structure and interfacial behaviour.

Ionic Liquid As An Effective Solvent For Cell Wall Deconstructing Through Astaxanthin Extraction From Haematococcus Pluvialis

Microwave-assisted extraction of lipids from microalgae using an ionic liquid solvent [BMIM][HSO4]

Extraction and separation of astaxanthin with the help of pre-treatment of Haematococcus pluvialis microalgae biomass using aqueous two-phase systems based on deep eutectic solvents

Selective Separation of Tocopherol Homologues by Liquid−Liquid Extraction Using Ionic Liquids

Comparison of Different Methods for Extracting the Astaxanthin from Haematococcus pluvialis: Chemical Composition and Biological Activity

Application of Ionic Liquids in the Microwave-Assisted Extraction of Proanthocyanidins from Larix gmelini Bark

Cell Wall Breaking of Haematococcus pluvialis Biomass Facilitated by Baijiu jiuqu Fermentation with Simultaneously Production of Beverages

Extraction of lutein by aqueous two-phase system including both cholinium and imidazolium-based ionic liquids from wet microalgae

Ionic Liquids toward Enhanced Carotenoid Extraction from Bacterial Biomass

Enhanced toxicity-free astaxanthin extraction from Haematococcus pluvialis via concurrent cell disruption and demulsification

Research on the Cell Wall Breaking and Subcritical Extraction of Astaxanthin from Phaffia rhodozyma

Applications and Mechanisms of Ionic Liquids in Whole-Cell Biotransformation.

Extraction of Astaxanthin from Haematococcus pluvialis and Preparation of Astaxanthin Liposomes

Short alkyl-imidazolium ionic liquids enhanced in-situ transesterification of microalgae

Extraction of Low-Concentration Bio-Based Diols and Dicarboxylic Acids Using Ionic Liquid-Based Aqueous Two-Phase Systems: Experimental and Theoretical Studies

Chlorophylls Extraction from Spinach Leaves Using Aqueous Solutions of Surface-Active Ionic Liquids

Interplay between interfacial behaviour, cell structure and shear enables biphasic lipid extraction from whole diatom cells (Navicula sp.)

Using aqueous solutions of ionic liquids as chlorophyll eluents in solid-phase extraction processes

Pyrrolidinium Ionic Liquids as Effective Solvents for Lignin Extraction and Enzymatic Hydrolysis of Lignocelluloses

Extraction of a Docosahexaenoic Acid-Rich Oil from Thraustochytrium sp. Using a Hydrophobic Ionic Liquid

Heavy Metal Extraction under Environmentally Relevant Conditions Using 3-Hydroxy-2-Naphthoate- Based Ionic Liquids: Extraction Capabilities vs. Acute Algal Toxicity