Abstract:The advancement of the theory of droplet stability in the acoustic field is of significant value to the advancement of ultrasonic atomization and ultrasonic levitation technologies. In order to reveal the detailed mechanism of acoustic droplet instability and give the instability criterion for easy application. In this paper, a kinetic study of droplet Instability in standing wave acoustic field (19.8 kHz) is carried out through a combination of experiment, theoretical derivation and numerical calculation. The acoustic Instability of the droplet occurring near the wave node is mainly manifested in two typical modes: disk Instability and edge-sharpening Instability. The appearance of these two Instability modes depends on the relative magnitude of the standing wave field strength. Specifically, with the gradual enhancement of the intensity of the standing wave field, the Instability mode of the droplet will gradually change from disc instability to edge-sharpened instability.The droplets show obvious self-accelerating expansion in the equatorial plane during the Instability process. The positive feedback between the droplet aspect ratio and the negative pressure of acoustic radiation at the equator of the droplet, is the reason for the above self-accelerating behavior. The theoretical results obtained by derivation show that the amplitude of the negative acoustic radiation pressure at the droplet equator is proportional to the quadratic of the droplet aspect ratio. The surface tension of the droplet is the main factor hindering the deformation of the droplet, and the acoustic radiation suction at the equator is the main factor driving the deformation of the droplet. Based on this, the force equilibrium equation of the droplet interface is established, and the dimensionless criterion of acoustic droplet instability, i.e., the acoustic Weber number Wea, is derived. when Wea≤1, the droplet interface stays in equilibrium, and when Wea>1, the equatorial acoustic suction is larger than the surface tension, and the droplet instability occurs, and the average error between the experimental results and the theoretical results is only 9%.

Theoretical Analysis of Rayleigh–Taylor Instability on a Spherical Droplet in a Gas Stream

Theoretical study on the interfacial instability of a spherical droplet subject to vertical vibration

Instability of Gas-Surrounded Rayleigh Viscous Jets: Weakly Nonlinear Analysis and Numerical Simulation

Rayleigh-Taylor Instability on the Surface of a Droplet under the Action of Ultrasonic Waves

Analytical Instability Theory of a Liquid Jet under a Thermal Field

Experimental Investigation on the Atomization of a Spherical Droplet Induced by Faraday Instability

Deformation Characteristics of Droplet Generated by Rayleigh Jet Breakup

STABILITY ANALYSIS OF VISCOELASTIC LIQUID DROPLETS EXCITED BY RADIAL OSCILLATIONS

Effects of Viscosity and Elasticity on Rayleigh–Taylor Instability in a Cylindrical Geometry

The Shrinking Instability of Toroidal Liquid Droplets in the Stokes Flow Regime

Elastic Rayleigh–Taylor and Richtmyer–Meshkov Instabilities in Spherical Geometry

Rayleigh-Taylor Instability at Spherical Interfaces of Incompressible Fluids

Experimental investigation of three-dimensional Rayleigh–Taylor instability of a gaseous interface

Analytical Model of Nonlinear Evolution of Single-Mode Rayleigh–Taylor Instability in Cylindrical Geometry

Nonlinear Threshold of Two-Dimensional Rayleigh-Taylor Growth for Incompressible Liquid

Nonuniform Approach to Terminal Velocity for Single Mode Rayleigh-Taylor Instability

Stability of an Annular Viscous Liquid Jet in Compressible Gases with Different Properties Inside and Outside of the Jet

Swirling Instability of Coaxial Liquid Jet in Gas Surroundings

NUMERICAL SIMULATION OF RAYLEIGH–TAYLOR INSTABILITY BASED ON AN IMPROVED PARTICLE LEVEL SET METHOD

Dynamics of Acoustically-Induced Droplet Instability

Thermal Effects on the Instability of Coaxial Liquid Jets in the Core of a Gas Stream