Abstract:Particle number (PN) emissions from hybrid electric vehicles (HEV) during engine ignition and re-ignition events are an important but scarcely reported area. The objectives of the present work are to study the effects of drive cycle properties on the engine behaviour of a hybrid electric vehicle (HEV) and to investigate how this impacts the tailpipe PN emissions and their size distributions (PNSD). Worldwide harmonised light vehicles test cycle (WLTC) testing was conducted, as well as chassis dynamometer emission measurements over a realistic real driving emissions (RDE) speed pattern, using a Euro 5 Toyota Prius HEV with a Cambustion DMS500 sampling PN concentrations at the tailpipe. It is shown that the number of vehicle stops during a test cycle has a direct impact on the re-ignition activity for the HEV. 64 ± 3% of the total PN from WLTC testing was produced during engine re-ignition events while only 6 ± 1% was from stabilised engine operation. Similar proportions were observed for the RDE-style test cycle. The majority of engine reignition and destabilised activity, and hence PN emission, was during the low-speed sections of the drive cycles used. The average PNSD across cycle phases was different between cycles, due to the influence of dynamic properties on engine behaviour and hence the PN emission profile. The PNSD at the engine re-ignition and destabilised events had a merged wide peak with a maximum at 60 nm diameter and a shoulder at 12 nm diameter. The HEV had increased emissions of particles smaller than 23 nm under cold start, but similar overall PN emission values, compared to a warm start. The results of this work highlight the importance of controlling HEV PN emissions to limit human exposure to PN in urban environments where the majority of PN emissions occur. The sensitivity of HEV PN emission factors and PNSD to engine behaviour and, in turn, test cycle dynamic properties, is important to note when considering legislative test cycles, particularly with reference to the freedoms afforded by the RDE test cycle. The results also indicate that substantial improvements to air quality could be made by reducing the particle measurement protocol PN cut-off size to 10 nm.

Real Driving Particle Number (PN) Emissions from China-6 Compliant PFI and GDI Hybrid Electrical Vehicles

Emission Characteristics of Particle Number from Conventional Gasoline and Hybrid Vehicles

RDE PN Emission Challenges for a China 6 PHEV

Characterizing the particle number emissions of light-duty gasoline vehicles under different engine technologies and driving conditions

Characteristics of Instantaneous Particle Number (PN) Emissions from Hybrid Electric Vehicles under the Real-World Driving Conditions

Particle Number Emissions from Light-Duty Gasoline Vehicles in Beijing, China.

Research on Particle Emissions of Light-duty Hybrid Electric Vehicles in Real Driving

Particle Number and Size Distributions (PNSD) from a Hybrid Electric Vehicle (HEV) over Laboratory and Real Driving Emission Tests

Sub-23nm Particle Emissions from China6 Gasoline Vehicles over Various Driving Cycles

Proceedings of Real Driving Emission (RDE) Measurement in China

Green Traffic-Oriented Heavy-Duty Vehicle Emission Characteristics of China VI Based on Portable Emission Measurement Systems

Comparative Analysis of Emission Characteristics of In-Use China II–V Gasoline, Hybrid, Diesel-Fueled Vehicles

Impact of Shortening Real Driving Emission (RDE) Test Trips on CO, NOX, and PN10 Emissions from Different Vehicles

Comparison of NOx and PN Emissions Between Euro 6 Petrol and Diesel Passenger Cars under Real-World Driving Conditions.

Using a Chassis Dynamometer to Determine the Influencing Factors for the Emissions of Euro VI Vehicles

Sub-23 nm Particle Emissions from China-6 GDI Vehicle: Impacts of Drive Cycle and Ambient Temperature

Impact of Test Cycle on Mass, Number and Particle Size Distribution of Particulates Emitted from Gasoline Direct Injection Vehicles

Research on Emission Characteristics of China VI Heavy-duty Hybrid Electric Vehicles

Characterizing Particulate Polycyclic Aromatic Hydrocarbon Emissions from Diesel Vehicles Using a Portable Emissions Measurement System

Effects of fuel and driving conditions on particle number emissions of China-VI gasoline vehicles: based on corrections to test results

The impacts from cold start and road grade on real-world emissions and fuel consumption of gasoline, diesel and hybrid-electric light-duty passenger vehicles