Abstract:The mechanism of convective drying of single coarse lignite particles has important theoretical and practical significance for the development of the lignite drying technologies. The drying kinetics of single lignite particles in hot air were investigated experimentally with particles diameters of 20 and 30 mm. The experiments were performed at hot air velocities of 0.7 and 1.5 m/s and hot air temperatures of 100 and 140 °C. The results from these experiments show that the lignite particle size, the hot air temperature, and the velocity all significantly influence the drying. For the range of operating conditions investigated in this study, the drying time was reduced by increasing the temperature and velocity of the hot air flow and decreasing the particle size. The constant drying rate period was not obvious with the lignite characterized by a long decreasing drying rate. Both types of lignite had a good linear relationship between the drying rate and the dry-basis moisture content. A mathematical model for the drying of single particles was developed assuming local thermodynamic equilibrium to describe the multiphase flow in the porous particle with the energy and mass conservation equations to describe the heat and mass transfer during the drying. The drying model included convection of the free water, diffusion of the bound water, and convection and diffusion of the gas mixture in the lignite particle. The numerical results agree well with the experimental data verifying that the mathematical model can evaluate the drying performance of porous lignite particles. The effects of the drying conditions such as the particle size, the temperature, the absolute humidity, and the velocity of the drying air on the drying process were evaluated using the numerical model.

Non-equilibrium thermodynamics approach for the coupled heat and mass transfer in microwave drying of compressed lignite sphere

Non-equilibrium Thermodynamics Approach for the Coupled Heat and Mass Transfer of Wet Mineral Porous Media in Dielectric and Magnetic Drying

Modeling Simultaneous Heat and Mass Transfer for Microwave Drying on Apple

Fluidized Bed Drying and Devolatilization of Lignite Washery Tailing Particles: Experiments and Modeling

Experimental and Numerical Investigation of Convective Drying of Single Coarse Lignite Particles

Numerical simulation of low-rank coal drying based on non-equilibrium thermodynamics

Mass-Transfer Simulation Software Study of Sliced Porous Production During Convection Drying Process

Probe into the adaptability of local equilibrium/non-equilibrium assumptions in simulating freeze-drying of porous media

Numerical simulation of single lignite particle drying process in high temperature flue gas

Thermodynamic analysis of moist coal during microwave heating using coupled electromagnetic, multi-phase heat and mass transfer model

Numerical Simulation of Lignite Drying in a Packed Moving Bed Dryer

Modeling of Muti-layer Far-Infrared Dryer

Numerical modeling of drying from saturated to unsaturated conditions with two-phase partitioning boundaries at the medium surface and interface-dependent phase change

Experimental and Numerical Investigation of Lignite Particle Drying in A Fixed Bed

Thermodynamic Analysis on A Lignite-Fired Power System Integrated with A Steam Dryer: Investigation on Energy Supply System of the Dryer

Numerical and experimental investigation of convective drying in unsaturated porous media with bound water

Simulation study on additive-promoted microwave dehydration of lignite

STUDY ON SINGLE LIGNITE PARTICLE DRYING PROCESS BY HOT GAS

A Thermo-Hydro-Mechanics Bidirectional Coupling Mathematical Model for Drying of Biological Porous Medium

Drying characteristics of oil shale under microwave heating based on a fully coupled three-dimensional electromagnetic-thermal-multiphase transport model

Microwave Drying of Food and Agricultural Materials: Basics and Heat and Mass Transfer Modeling