Abstract:Low-temperature selective catalytic reduction (SCR) is an economical and feasible technology to effectively reduce NOx emissions from combustion sources. However, low-temperature SCR still suffers from low activity and SO2/H2O poisoning of catalysts. Here, a strategy to promote SCR activity and anti-poisoning ability was proposed through enhancing the metal–metal interaction. Ternary ferrite spinel material (CuMnFeO4) with a stronger metal–metal interaction was synthesized through incorporating Mn cations into the tetrahedral sites of CuFe2O4 spinel. CuMnFeO4 spinel mainly exists in an amorphous form and shows good SCR performance and SO2/H2O anti-poisoning ability in the temperature window of 200–350 °C. Density functional theory calculations were used to investigate the atomic-level reaction mechanism of NO reduction. Theoretical results indicate that NO and NH3 adsorptions over the CuMnFeO4 catalyst are controlled by the chemisorption mechanism. The interaction between reactants (NO and NH3) and the CuMnFeO4 surface is closely associated with the orbital hybridization of N and Fe atoms. The SCR reaction of NO with NH3 over the CuMnFeO4 catalyst is governed by a six-step process (NO → NO* → H2NNO* → HNHNO* → HNNOH* → N2* → N2), in which the first H-transfer reaction (H2NNO* → HNHNO*) presents the highest activation energy barrier of 230.84 kJ/mol and is the rate-determining step of the NH3-SCR reaction. Finally, a SCR cycle reaction scheme was proposed to understand the reaction process of NO reduction over CuMnFeO4 spinel.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.energyfuels.0c02293?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.energyfuels.0c02293</a>.BET surface area and average pore diameter of different catalysts (Table S1), schematic diagram of the experimental system for NO reduction (Figure S1), and crystal structure of CuMnFeO4 spinel, octahedral Cu2+ cation, tetrahedral Mn3+ cation, octahedral Fe3+ cation, and CuMnFeO4(100) surface (Figure S2) (<a class="ext-link" href="/doi/suppl/10.1021/acs.energyfuels.0c02293/suppl_file/ef0c02293_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Active Tetrahedral Iron Sites of Γ-Fe2o3 Catalyzing NO Reduction by NH3

Simultaneously Enhancing Stability and Activity of Maghemite Via Site‐Specific Ti(IV) Doping for NO Emission Control

Fe-Ti spinel for the selective catalytic reduction of NO with NH 3: Mechanism and structure-activity relationship

Structural Effects of Iron Spinel Oxides Doped with Mn, Co, Ni and Zn on Selective Catalytic Reduction of NO with NH3

Insight into highly efficient FeOx catalysts for the selective catalytic reduction of NOx by NH3: Experimental and DFT study

In Situ DRIFTS Studies of NH3-SCR Mechanism over V2O5-CeO2/TiO2-ZrO2 Catalysts for Selective Catalytic Reduction of NOx

Comparative Study of Different Doped Metal Cations on the Reduction, Acidity, and Activity of Fe9m1ox (M = Ti4+, Ce4+/3+, Al3+) Catalysts for Nh3-Scr Reaction

Single-Atom Catalysts Reveal The Dinuclear Characteristic Of Active Sites In No Selective Reduction With Nh3

A novel high activity MnXFe3−XO4 spinel catalyst for selective catalytic reduction of NO using NH3 prepared by a short process from natural minerals for low-temperature sintering flue gas: Effect of X value on catalytic mechanism

Optimizing Selective Catalytic Reduction of NO with NH3 on Fe2O3/WO3 Via Redox‐Acid Synergy

Enhanced Selective Catalytic Reduction of NOx with NH3 over Homoatomic Dinuclear Sites in Defective Α-Fe2o3

Effect of iron loading on the performance and structure of Fe/ZSM-5 catalyst for the selective catalytic reduction of NO with NH3

Catalytic Performance, Characterization, and Mechanism Study of Fe-2(So4)(3)/Tio2 Catalyst for Selective Catalytic Reduction of Nox by Ammonia

Study on the Effect of Fe Doping on SCR Activity and Reaction Mechanism of Mn–TiO2 Catalysts

Transition metals (Co, Zr, Ti) modified iron-samarium oxide as efficient catalysts for selective catalytic reduction of NOx at low-temperature

A Study of the Mechanism of Iron‐based Sulfate Catalyst for Selective Catalytic Reduction of NO with NH3

Active sites of NO selective catalytic reduction over V2O5-WO3/TiO2

De-reducibility Mechanism of Titanium on Maghemite Catalysts for the SCR Reaction: an in Situ DRIFTS and Quantitative Kinetics Study

Promotional effect of iron oxide on the catalytic properties of Fe–MnOx/TiO2 (anatase) catalysts for the SCR reaction at low temperatures

Metal–Metal Interactions of Ternary Spinel for Efficient NH 3 Selective Catalytic Reduction of NO x at a Low Temperature

Activity enhancement of WO3 modified FeTiO catalysts for the selective catalytic reduction of NO by NH3