Abstract:The qualitative and quantitative composition of volatile compounds in fermented distillery mash determines the quality of the obtained distillate of agricultural origin (i.e., raw spirit) and the effectiveness of further purification steps. Propan-2-ol (syn. isopropyl alcohol), due to its low boiling point, is difficult to remove by rectification. Therefore, its synthesis needs to be limited during fermentation by Saccharomyces cerevisiae yeast, while at the same time controlling the levels of acetaldehyde and acetic acid, which are likewise known to determine the quality of raw spirit. Lactic acid bacteria (LAB) are a common but undesirable contaminant in distillery mashes. They are responsible for the production of undesirable compounds, which can affect synthesis of propan-2-ol. Some bacteria strains are able to synthesize isopropyl alcohol. This study therefore set out to investigate whether LAB with S. cerevisiae yeast are responsible for conversion of acetone to propan-2-ol, as well as the effects of the amount of LAB inoculum and fermentation parameters (pH and temperature) on the content of isopropyl alcohol, acetaldehyde, lactic acid and acetic acid in fermented mashes. The results of NMR and comprehensive two-dimensional gas chromatography coupled with time of flight mass spectrometry (GC × GC-TOF MS) analysis confirmed the ability of the yeast and LAB strains to metabolize acetone via its reduction to isopropyl alcohol. Efficient fermentation of distillery mashes was observed in all tested mashes with an initial LAB count of 3.34–6.34 log cfu/mL, which had no significant effect on the ethanol content. However, changes were observed in the contents of by-products. Lowering the initial pH of the mashes to 4.5, without and with LAB (3.34–4.34 log cfu/mL), resulted in a decrease in propan-2-ol and a concomitant increase in acetaldehyde content, while a higher pH (5.0 and 5.5) increased the content of propan-2-ol and decreased acetaldehyde content. Higher temperature (35 °C) promoted propan-2-ol synthesis and also resulted in increased acetic acid content in the fermented mashes compared to the controls. Moreover, the acetic acid content rose with increases in the initial pH and the initial LAB count.

Behaviour of ethyl caproate during the production and distillation of ethyl caproate‐rich rice shochu

Development of a process for producing ethyl caproate‐ and ethyl lactate‐rich rice shochu

Vinegar Production from Post-Distillation Slurry Deriving from Rice Shochu Production with the Addition of Caproic Acid-Producing Bacteria Consortium and Lactic Acid Bacterium.

Enhanced Ethyl Caproate Production of Chinese Liquor Yeast by Overexpressing EHT1 with Deleted FAA1

Production of Rice Liquor with a High Concentration Flavor from Post - Distillation Slurry (2)

Development Of Efficient Shochu Production Technology With Long-Term Repetition Of Sashimoto And Reuse Of Stillage For Fermentation

Isolation and Identification of a High-Yield Ethyl Caproate-Producing Yeast From Daqu and Optimization of Its Fermentation

Selection and application of potential whole‐cell enzymes in the esterification of Huangshui, a by‐product formed during Chinese liquor‐making

Effects of Ethanol Addition on Caproic Production and Rumen Microorganism Community Structure from Straw Fermentation

Production of Medium-Chain Fatty Acid Caproate from Chinese Liquor Distillers' Grain Using Pit Mud As the Fermentation Microbes

High concentration ethanol production from corncob residues by fed-batch strategy.

Characterization of Volatile Flavor Compounds in Chinese Rice Wine Fermented from Enzymatic Extruded Rice

Analysis of ester-producing performance in high-yield ethyl hexanoate yeast and the effect on metabolites in bio- enhanced Daqu, the starter for Baijiu and other traditional fermented foods

Improved ethyl caproate production of Chinese liquor yeast by overexpressing fatty acid synthesis genes with OPI1 deletion

Caproiciproducens converts lactic acid into caproic acid during Chinese strong-flavor Baijiu brewing

Effect of Co-Inoculation with Saccharomyces cerevisiae and Lactic Acid Bacteria on the Content of Propan-2-ol, Acetaldehyde and Weak Acids in Fermented Distillery Mashes

Regulation of hydraulic retention time on caproic acid production via two-phase anaerobic fermentation of Chinese cabbage waste with autopoietic electron donors

Caproic Acid-Producing Bacteria in Chinese Baijiu Brewing

Enhancing Synthesis of Ethyl Lactate in Rice Baijiu Fermentation by Adding Recovered Granular Cells

Unraveling Physicochemical Characteristics, Microbial Community Structure and Functional Enzymes Governing Fatty Acid Ethyl Esters Formation During Chinese Rice Wine Brewing

Effect of Koji on Flavor Compounds and Sensory Characteristics of Rice Shochu