Abstract:Bioethanol can be produced from several biomasses including lignocellulosic materials. Besides 6-carbon sugars that represent the prevalent carbohydrates, some of these feedstocks contain significant amounts of 5-carbon sugars. One common limit of the major part of the xylose-fermenting yeasts is the diauxic shift between the uptake of glucose and xylose during the fermentation of mixed syrups. Thus, optimized fermentation strategies are required. In this paper the ability of Scheffersomyces stipitis strain NRRLY-11544 to ferment mixed syrups with a total sugar concentration in the range 40-80 g/L was investigated by using mono cultures, co-cultures with Saccharomyces cerevisiae strain Bakers Yeast Type II and single cultures immobilized in silica-hydrogel films. The experimental design for the fermentations with immobilized cells included the process analysis in function of two parameters: the fraction of the gel in the broth and the concentration of the cells loaded in the gel. Furthermore, for each total sugars level, the fermentative course of S. stipitis was analyzed at several glucose-to xylose ratios. The results indicated that the use of S. stipitis and S. cerevisiae in free co-cultures ensured faster processes than single cultures of S. stipitis either free or immobilized. However, the rapid production of ethanol by S. cerevisiae inhibited S. stipitis and caused a stuck of the process. Immobilization of S. stipitis in silica-hydrogel increased the relative consumption rate of xylose-to-glucose by 2-6 times depending on the composition of the fermentation medium. Furthermore the films performances appeared stable over three weeks of continuous operations. However, on the whole, the final process yields obtained with the immobilized cells were not meaningfully different from that of the free cells. This was probably due to concurrent fermentations operated by the cells released in the broth. Optimization of the carrier characteristics could improve the performances of the process with immobilized cells.

Sequential Co-Immobilization of Β-Glucosidase and Yeast Cells on Single Polymer Support for Bioethanol Production

Ethanol Fermentation on Xylose by Immobilized Recombinant Yeast

Enzymatic hydrolysis of biomass with recyclable use of cellobiase enzyme immobilized in sol–gel routed mesoporous silica

Net-Immobilization of Β-Glucosidase on Nonwoven Fabrics to Lower the Cost of “cellulosic Ethanol” and Increase Cellulose Conversions

Synergetic Saccharification and Lactic Acid Fermentation by Coimmobilized Cells Using Cellulosic Materials

Layered Co-Immobilization of Β-Glucosidase and Cellulase on Polymer Film by Visible-Light-Induced Graft Polymerization

Lactic acid production by coimmobilized cells using cellulosic hydrolysate

Facile Construction of Synergistic Β-Glucosidase and Cellulase Sequential Co-immobilization System for Enhanced Biomass Conversion

Cytocompatible Fabrication of Yeast Cells/Fabrics Composite Sheet for Bioethanol Production.

Porous PEG Scaffold Fabricated via Emulsion-Templating Technique Towards Immobilization of Saccharomyces cerevisiae Cells

Bioethanol production by reusable Saccharomyces cerevisiae immobilized in a macroporous monolithic hydrogel matrices

Reversible Adsorption and Detachment of Saccharomyces cerevisiae on Thermoresponsive Poly( N -isopropylacrylamide)-Grafted Fibers for Continuous Immobilized Fermentation

Immobilization-Stabilization of β-Glucosidase for Implementation of Intensified Hydrolysis of Cellobiose in Continuous Flow Reactors

Immobilization of Zymomonas mobilis with Fe2O3-modified polyvinyl alcohol for continuous ethanol fermentation

Cell Immobilization Using Alginate-Based Beads as a Protective Technique against Stressful Conditions of Hydrolysates for 2G Ethanol Production

Macroporous hydrogel prepared via aqueous polymerization induced phase separation toward in situ immobilization of yeast

Bioethanol production from mixed sugars by Scheffersomyces stipitis free and immobilized cells, and co-cultures with Saccharomyces cerevisiae

Production of recombinant β-glucosidase and simultaneous immobilization and purification using immobilized metal ion affinity membrane