Effect of Maize Straw Storage Practice on Biogas Production Performance During Anaerobic Co-Digestion with Cattle Manure
Ren Haiwei,Yao Xingquan,Li Jinping,Li Zhizhong,Wang Xin,Wang Chunlong,Zhang Dianping,Sun Yongming
DOI: https://doi.org/10.3969/j.issn.1002-6819.2014.18.027
2014-01-01
Abstract:The use of energy crops as feedstock for biogas production is increasing. Since energy crops accumulate seasonally but biogas plants have to be fed continuously, the feedstock has to be conserved. Therefore, the storage of energy crops is an important issue to handle, as crops need to be available throughout the year. Research on preservation and storage of energy crops as feedstock for anaerobic digestion is still at an emerging stage. The aim of this paper is to explore the effects of storage methods (air drying or ensiling) of maize straw on biogas production performance. Evaluations of anaerobic co-fermentation of maize straw and cattle manure were conducted by batch fermentation in a laboratory scale. Biogas production was measured for 45 days in 1.5L batch digesters at mesophilic conditions of 37℃. First, the chemical composition and structural properties of air-dried maize straw (ADMS) and ensiled maize straw (EMS) were comparatively analyzed. Then, the effects of total solids (TS) mixing ratios (cattle manure: maize straw) on biogas conversion were discussed. TS mixing ratios (TMR) were 1:1, 3:7, 7:3, 4:6, and 6:4, respectively. The dynamic analysis of daily biogas production, accumulative biogas production, accumulative methane production, and pH value was implemented. The results show that ensiling had little effect on the cellulosic composition of EMS, however water and WSC of ADMS nearly vanished. In other words, the properties of the maize straw were influenced by the method of storage. The results of SEM and XRD indicate that the lignocellulosic matrix of ADMS is compact, but cracks and ruleless pores were taken on the surfaces of EMS, signaling that the crystalline degree of cellulose was lower than that of ADMS. Storage by ensiling can be considered as a pretreatment process, because the structural polysaccharides of maize straw, which is quite resistant to anaerobic digestion, are partly degraded during storage. Results also show that the anaerobic efficiency of biogas production, the cumulative biogas yield, TS/VS biogas yield, and TS/VS methane yield were highest when the TMS was 7:3, whether ADMS or EMS. The accumulative methane production of EMS was higher than that of ADMS when the TMS was 1:1, and the highest accumulative methane production was 1 816 mL when the TMS was 7:3. The present results demonstrate that the biogas yield of maize straw can be maintained by appropriate ensiling conditions for even after 8 months. Ensiling, which acts as a pretreatment step, showed positive effects on the methane yield of maize straw, and the degradation of structural polysaccharides into more easily degradable intermediates caused the increase in biogas potential after ensiling. In conclusion, ensiling is an appropriate, feasible storage method to preserve fresh crops throughout the year for an anaerobic digestion facility in order to ensure a predictable quality of crops and a constant supply of feedstock.