Abstract:In this paper, an exploration of the practical thermodynamic performance limits of the organic Rankine cycle (ORC) under working fluid and cycle parameter restrictions is presented. These performance limits are more realistic benchmarks for the thermodynamic cycle than the efficiency of the Carnot cycle. Subcritical ORC configuration with four typical case studies that are related to temperature ranging from 373.15 to 673.15 K is taken into account. The ORC is defined by its cycle parameters and working fluid characteristic properties. The cycle parameters involve evaporation temperature ( T eva ), condensation temperature ( T con ) and superheat degree (Δ T sup ), while the working fluids are represented by the characteristic properties including critical temperature ( T c ), critical pressure ( p c ), acentric factor ( ω ), and molar ideal gas isobaric heat capacity based on the principle of corresponding states. Subsequently, Pareto optimum solutions for obtained hypothetical working fluids and cycle parameters are achieved using multi-objective optimization method with the consideration of both thermal efficiency ( η th ) and volumetric power output (VPO). Finally, sensitivity analysis of the working fluid characteristic properties is conducted, and the second law of thermodynamics analysis, especially the applicability of entropy generation minimization, is performed. The results show that the current commonly used working fluids are widely scattered below the Pareto front that represents the tradeoff between η th and VPO for obtained hypothetical fluids. T eva and T con are the most dominant cycle parameters, while T c and ω tend to be the most dominant characteristic property parameters. The entropy generation minimization does not give the same optimal results.

Investigation on A Small-Scale Pumpless Organic Rankine Cycle (orc) System Driven by the Low Temperature Heat Source

Investigation on an Innovative Cascading Cycle for Power and Refrigeration Cogeneration

Analysis of a 1 Kw Organic Rankine Cycle Using a Scroll Expander for Engine Coolant and Exhaust Heat Recovery

Working Fluid Selection for a Small-Scale Organic Rankine Cycle Recovering Engine Waste Heat

Comparative Analysis of Small-Scale Organic Rankine Cycle Systems for Solar Energy Utilisation

Experimental Investigations on Dynamic Performance of Organic Rankine Cycle Integrated with Latent Thermal Energy Storage under Transient Engine Conditions

Experimental investigation on a small pumpless ORC (organic rankine cycle) system driven by the low temperature heat source

Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source

Comparison study of Trilateral Rankine Cycle, Organic Flash Cycle and basic Organic Rankine Cycle for low grade heat recovery

Energy, Exergy, Economic Performance Investigation and Multi-Objective Optimization of Reversible Heat Pump-Organic Rankine Cycle Integrating with Thermal Energy Storage

Experimental Study on a Small-Scale Pumpless Organic Rankine Cycle with R1233zd(E) As Working Fluid at Low Temperature Heat Source

Experimental Investigation on a Small-Scale ORC System with a Pump Driven by Internal Multi-Potential

Non-steady thermodynamic characteristics of a pilot-scale organic Rankine cycle system with a thermally-driven pump

Investigations on Experimental Performance and System Behavior of 10 Kw Organic Rankine Cycle Using Scroll-Type Expander for Low-Grade Heat Source

Operation and performance of a low temperature organic Rankine cycle

Technical Feasibility of a Gravity-Type Pumpless ORC System with One Evaporator and Two Condensers

Thermodynamic Analysis of A Low-Temperature Organic Rankine Cycle Power Plant Operating at Off-Design Conditions

Investigation on a Novel Pumpless Module Driven by Thermal Energy and Gravity and Its Application in an ORC System

Energetic and Exergetic Investigation of an Organic Rankine Cycle at Different Heat Source Temperatures

Construction and dynamic test of a small-scale organic rankine cycle

Analysis of the Thermodynamic Performance Limits of the Organic Rankine Cycle in Low and Medium Temperature Heat Source Applications