Abstract:With the rapid increasing interest on the space exploration, the reliability of the spacecraft becomes a very important problem. The space solar power station (SSPS) is inevitably exposed to space plasma, energetic particles radiation, extreme temperature, cosmic rays, etc. Energetic electrons can penetrate through the aluminum shield and deposit in the deep-layer of insulating materials, leading to partial accumulation of space charges and high electric field. Electrostatic discharge (ESD) occurs when the maximum electric field of insulating materials exceeds a certain threshold, resulting in deterioration of the insulating material and even the failure of the entire electronic equipment. Deep-layer dielectric charging has been the key scientific issue for developing high-voltage and high-power spacecraft technology. In this paper, a physical model is established to simulate the deep-layer charging characteristics of ethylene-tetrafluoro-ethylene (ETFE) under FLUMIC spectrum electron irradiation, based on the processes of carriers' transport and deposition of charge and energy. Two operating conditions, i.e. typical GEO condition and extreme GEO condition with varied flux enhancement, are studied. In addition, the possibility of suppressing the deep dielectric charging properties of ETFE by the addition of nano-boroncarbide (nano-B4C) is also investigated. The calculation results show that the maximum electric field in the deep-layer of ETFE rapidly reaches 108 V/m under extreme GEO space environment. Electrostatic discharge is easily to take place as it exceeds the breakdown threshold. It is found that the time spent to reach the maximum value of potential and electric field is less than one minute under extreme space radiation environment. Furthermore, the addition of nano-B4C can suppress the deep dielectric charging properties of ETFE to a large extent by introducing more shallow traps. This provides a potential approach on suppressing the deep dielectric charge accumulation.

CALCULATION OF CARRIER MOBILITY IN SPACE INSULATER BY THE THERMALLY STIMULATED CURRENT

Charge Transport Properties of Dielectrics Revealed by Isothermal Surface Potential Decay

Thermally stimulated current investigations on the insulation

Investigation into Surface Potential Decay of Polyimide by Unipolar Charge Transport Model

Charge Transport Properties of Insulators Revealed by Surface Potential Decay Experiment and Bipolar Charge Transport Model with Genetic Algorithm

Measurement of Carrier Mobility in Polyethylene based on the Pulsed Electro-acoustic Method

The effect of temperature on charging behaviour of polyimide subjected to electron beam at vacuum

Carrier Mobility of Polyethylene and Mechanism of Space Charge Packet Formation

Research of deep dielectric charging characteristics of polytetrafluoroethene irradiated by energetic electrons

A simulation of deep dielectric charging induced by dielectric temperature and energetic electrons

A New Method for Carrier Mobility Measurement in Oil Immersed Cellulose Paper Insulation

Thermally Stimulated Discharge Current Analysis of Polymeric Solid-State Ionic Conductors

Space Charge Behavior in Polymeric Materials under Temperature Gradient

Research of migration behavior of space charge packet in polyethylene by electron beam irradiation method under the applied electric field

Study on Charge Transport Mechanism and Space Charge Characteristics of Polyimide Films

Experimental Research and Numerical Simulation on Deep Charging for Spacecraft Dielectrics

Numerical Simulation of Space Charge Packet Behavior in Low-Density Polyethylene under Direct Current Voltage

Simulation of low-energy electron beam irradiated PTFE based on bipolar charge transport model

Study Of Deep Dielectric Charging Characteristics And Suppression Method Under Space Irradiation Environment

The Measurement of TSC in Solid Insulation with Inverter Driven Motors

Measurements of Charge Carrier Mobility in Oil Immersed Paper Insulation by the Means of Pulsed Electro-Acoustic Method