Abstract:Small-scale laboratory experiments of airflow through a single burner model and industrial-scale experiments on the centrally fuel-rich, low NOx swirl burner on a 300-MW wall-fired subcritical boiler burning low-volatile coal under deep air staging were performed. The aerodynamic characteristics, flue gas temperature, and gas concentrations were measured for various vane angles of outer secondary air in the burner nozzle region. The results show that a stable, symmetric central reverse-flow zone forms close to the exit of the burner nozzle region under deep air staging. With decreasing vane angle, i) the maximum axial, radial, and tangential velocities and swirl intensity of the airstream increase; ii) the decaying rate of velocity increases between X/D = 0 and X/D = 0.8; iii) the maximum diameter, length, and the jet divergence angle of the central reverse-flow zone increase; and iv) the relative reverse-flow rate increases. While the primary air concentration decreases slightly, the maximum primary air concentration decreases rapidly with decreasing vane angle. In contrast, the maximum axial relative mixing rate increases in the initial stage along the airstream direction. A decrease in vane angle increases the flue gas temperature, the rate of increase indicating a closer ignition position of the anthracite and lean coal along the airstream direction of the burner. The O-2 consumption rate and NOx formation rate increase in the initial stage of combustion, whereas in the later stage the CO concentration increases notably and the O-2 concentration remains almost constant below 1%. The CO concentration can exceed 20,000 ppm, which restrains the NOx formation and reduces the NOx concentration notably, but beyond X' = 0.8 m, the NOx concentration remains almost constant. The flue gas temperature varies slightly for different vane angles in the side-wall region. The O-2 concentration exceeds 4% near the location of the water-cooled wall. The O-2 concentrations are below 2% and the CO concentrations are above 5000 ppm along the radial direction 1.8375 m <= R' <= 2.3375 m from the centerline of the burner in the side-wall region. With decreasing vane angle, the CO concentration increases while the NOx concentration decreases. (C) 2016 Energy Institute. Published by Elsevier Ltd. All rights reserved.

Experimental Study on Combustion Adjustment for Dense-dilute Burning Through Swirling Burner with Variable Flaring Angle

Experimental and Numerical Study of a Two-Stage Swirl Burner

Combustion Characteristics and NOx Emission Through a Swirling Burner with Adjustable Flaring Angle

Effect of the Adjustable Inner Secondary Air-Flaring Angle of Swirl Burner on Coal-Opposed Combustion

Numerical analysis of the effect of swirl angle and fuel equivalence ratio on the methanol combustion characteristics in a swirl burner

Combined control of secondary air flaring angle of burner and air distribution for opposed-firing coal combustion

Numerical and Experimental Assessment of a Novel Multinozzle Burner with CO2 Diluent to Improve the Emissions from a Swirling Flame in a Combustion Chamber

Experimental Study And Numerical Simulation On A Novel Structure Of Dual Register Whirl Burner

Experimental study on flow and combustion characteristic of a novel swirling burner based on dual register structure for pulverized coal combustion

Experimental investigation on effect of over fire air equipping on a swirling burner on NOx emission and burnout ratio

Experimental Investigation of Low-Temperature Autoignition in Turbulent Premixed Swirling Flames

Experiment and numerical study on combustion characteristics of low-nitrogen burners

Low-Nox Modification of A Heavy Fuel Oil Swirl Burner Based on Semi-Industrial Scale Experimental Tests

Numerical Simulation of the Combustion Characteristics of a Low NOx Swirl Burner: Influence of the Primary Air Pipe

Experimental Study on Nox Emission and Unburnt Carbon of A Radial Biased Swirl Burner for Coal Combustion

Effect of vane angle on turbulence-chemistry interactions, temperature, flow field, burnout, and NOx emissions in swirling flames fueled by semicoke mixtures

Investigation of NOx emission under different burner structures with the optimized combustion model

Effect of Outer Secondary-Air Vane Angle on the Flow and Combustion Characteristics and Nox Formation of the Swirl Burner in A 300-Mw Low-Volatile Coal-Fired Boiler with Deep Air Staging

Influence of jet angle on diffusion combustion characteristics and NOx emissions in a self-reflux burner

Effect of Outer Secondary Air Vane Angles on Combustion Characteristics and NOx Emissions for Centrally Fuel Rich Swirl Burner in a 600-Mwe Wall-Fired Pulverized-Coal Utility Boiler

Experimental Research on the Primary-air Expansion Angle of a Coaxial Swirl and Stratified-flow Burner