Abstract:This study investigates the different synthesis methods of reduced graphene oxide and compares the reduction efficiency, structural, and morphological properties of the synthesized RGO by these methods. RGO synthesized by both chemical and thermal methods shows highly reduced GO with some defects, though thermally reduced GO produces higher degree of reduction similar to graphene. This study helps in identifying suitable reduction mechanism based on the applications. Graphene oxide (GO) is a single layer of carbon atoms obtained from the oxidation of graphite by the modified Hummers' method. Sulfuric acid acts as an intercalating agent and allows potassium permanganate to enter the layers to oxidize each layer of graphite to form GO. The resultant GO is highly hydrophilic and less conductive in nature. We further reduced it using a combination of thermal and chemical methods. Thermally reduced GO has been produced by thermal treatment of GO, and chemically reduced GO was obtained by two different reducing agents, such as l‐ascorbic acid and sodium borohydride. The degree of oxidation and the purity of the RGO were analyzed using Fourier transform infrared (FTIR), Raman spectroscopy, X‐ray diffraction (XRD), and scanning electron microscopy (SEM). FTIR analysis of GO revealed distinct absorption peaks of oxygen‐based functional groups that show a higher degree of oxidation of the carbon structure. Upon reduction, the FTIR spectrum exhibits a partial or total removal of the same, which signifies the loss of oxygen and the partial restoration of the graphitic structure. The results emphasize that the carbon‐to‐oxygen ratio was higher in both reduction methods, but thermal reduction yielded a greater degree of deoxygenation than the other.

Reduction of graphene oxide by UHV annealing

A Simplified Chemical Reduction Method for Preparation of Graphene: Dispersity, Reducibility and Mechanism

Effective reduction of graphene oxide thin films by a fluorinating agent: Diethylaminosulfur trifluoride

Mass spectrometry of graphene oxide thermal reduction in vacuum

Reduction and Structural Evolution of Graphene Oxide Sheets under Hydrothermal Treatment

Low-temperature thermal reduction of graphene oxide: In situ correlative structural, thermal desorption, and electrical transport measurements

Effect of Microwave Treatment in a High Pressure Microwave Reactor on Graphene Oxide Reduction Process-TEM, XRD, Raman, IR and Surface Electron Spectroscopic Studies

The Effect of Thermal Reduction on the Photoluminescence and Electronic Structures of Graphene Oxides

Reduction of a Single Layer Graphene Oxide Film on Pt(111)

Exploring Reduction Techniques for Graphene Oxide: A Comparative Study of Thermal and Chemical Methods

Solvent-Assisted Thermal Reduction of Graphite Oxide

Hydrothermal Dehydration for the "green" Reduction of Exfoliated Graphene Oxide to Graphene and Demonstration of Tunable Optical Limiting Properties

A New Reducing Agent to Prepare Single-Layer, High-Quality Reduced Graphene Oxide for Device Applications

Study on the structure of reduced graphene oxide prepared by different reduction methods

Graphene oxidation and reduction in medium vacuum by an UV lamp at 365 nm wavelength

Enhanced Deoxygenation Efficiency of Graphene Oxide under Solid-State Microwave Irradiation Via Chemical Pre-Reduction

Radiation induced reduction of Graphene Oxide: a dose effect study

Thermodynamic and Kinetic Analysis of Lowtemperature Thermal Reduction of Graphene Oxide

Simultaneous Nitrogen-Doping and Reduction of Graphene Oxide

Effective reduction of graphene oxide via a hybrid microwave heating method by using mildly reduced graphene oxide as a susceptor

Comparison of thermally and chemically reduced graphene oxides by thermal analysis and Raman spectroscopy