Fullerene (C60)‐doped zinc‐aluminium layered double hydroxide/polyvinyl alcohol nanocomposites: Synthesis, characterization, and photodegradation of methylene blue from water solution
Ofeliya O. Balayeva,Turkan Sh. Israfilli,Abdulsaid A. Azizov
DOI: https://doi.org/10.1002/jccs.202300313
2023-10-25
Journal of the Chinese Chemical Society
Abstract:Short caption: 1. The effect of C60 on the optical, structural, morphological properties, and photocatalytic activity of LDHs was investigated. 2. The basal spacing of C60‐doped ZnAl‐LDH was estimated to be 9.217 Å which is wide enough from the general LDH (~7.0 Å). 3. The maximal photodegradation efficiency was found with 20% of C60 doping (PD% = 96.98) after 360 min, where the sorption efficiency with this compound is very high (R% = 85.55). Introduction Layered double hydroxides (LDHs) are widely studied anionite clays consisting of positively‐charged hydroxide nanosheets which is described by the general formula: [M(II)1−xM(III)x(OH)2][An−·mH2O], where M(II) and M(III) are the divalent (e.g., Mg2+, Zn2+, Ca2+, Co2+, Ni2+, etc.) and trivalent (e.g., Al3+, Fe3+, Cr3+, etc.) metal ions, An− and H2O is the interlamellar anion (e.g., Cl ̄, Br ̄, NO3 ̄, CO32 ̄, SO42 ̄, SeO42 ̄) for charge‐neutralization and hydrated state, respectively. They have been widely used in different industry sectors, in materials science and research. Polymer/LDH nanocomposites have gained significant attention in recent years. Carbon‐based nanomaterials, like fullerene, carbon nanotubes (CNT), graphene and graphene oxide have attracted significant attention. Fullerene molecules (C60, C70) are used as reinforcing material for polymers to improve their mechanical, thermal, optical, energy storage and charge transport properties. Objectives C60‐doped ZnAl‐layered double hydroxide/polyvinyl alcohol nanocomposites were successfully synthesized and their photocatalytic activity for photodegradation of methylene blue (MB) synthetic dye was quantitatively analyzed by ultraviolet (UV) spectroscopy. The effect of C60 on the optical, structural, morphological properties, and photocatalytic activity of LDHs was investigated, and the impact of C60/LDH mass ratio and aging time on the properties was also studied. Methods Fullerene‐doped ZnAl‐LDH/PVA nanocomposites were synthesized via urea hydrolysis and coprecipitation‐coformation method. First, 10 wt% PVA/water solution (40 mL) is added into the mixed solution containing 0.015 mol of Zn(NO3)2·6H2O and 0.005 mol of Al2(SO4)3·9H2O and titrated by 2 M of NaOH and 1 M of NaHCO3 mixed base solution to adjust pH 9. The obtained white slurry was shaken very hard and aged for 1 year. The obtained samples were marked by the mass percentage of C60 as 1% C60@LDH/PVA, 10% C60@LDH/PVA, 20% C60@LDH/PVA, and 60% C60@LDH/PVA. Results and Discussion The basal spacing of C60‐doped ZnAl‐LDH was estimated to be 9.217 Å which is wide enough from the general LDH (~7.0 Å). The crystallite size of nanoparticles is 9.217 nm and ~6 nm by Scherrer's equation and Williamson–Hall method from the XRD data, respectively. Rice‐shaped 2D morphology was formed with 100 nm–2 μm width and 500 nm–10 μm in length by SEM. The maximal photodegradation efficiency was found with 20% of C60 doping (PD% = 96.98) after 360 min, where the sorption efficiency with this compound is very high (R% = 85.55). Conclusions In the presented work, the effect of C60 on the optical, structural, morphological properties, and photocatalytic activity of LDHs was investigated, and the impact of C60/LDH mass ratio and aging time on the properties was also studied. For the identification of the photocatalytic activity of obtained C60/LDH nanocomposites, MB was used as a model pollutant and the efficiency of the Zn/Al LDH nanocomposite, with various quantities of fullerene, is also evaluated.
chemistry, multidisciplinary