Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

A Trimming Methodology for a New Coaxial Rotor Configuration of Robotic Helicopter Based on Rotor's Thrust Ratio

A Minimal Thrust Vectoring Rotor with Six Degree of Freedom: Design and Analysis

A hybrid trim strategy for coaxial compound helicopter

Automated Design Optimization of a Mono Tiltrotor in Hovering and Cruising States

Propeller design to improve flight dynamics features and performance for coaxial compound helicopters

An rVPM-Based Aerodynamic Hybrid Optimization Method for Coaxial Rotor with Differentiated Upper and Lower Blades in Both Hover and High-Speed Cruising States

Design, Modeling, and Control of a Coaxial Drone

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

A Coupled CFD/Trim Analysis of Coaxial Rotors

Modeling and the Control Strategy of the Coaxial Contra-Rotating Propeller System

Aerodynamic analysis of rotor-to-rotor interactions in different octocopter configurations

Flight Dynamics Modeling, Trim, Stability, and Controllability of Coaxial Compound Helicopters

Design and dynamics of a novel parallel coaxial twin rotor of helicopter

Rotor Cross-Tilt Optimization of Manned Multi-rotor Evtol Aircraft for Yaw Control Efficiency

Aerodynamic Analysis of Rotor Spacing and Attitude Transition in Tilt-Powered Coaxial Rotor UAV

Influence of differential longitudinal cyclic pitch on flight dynamics of coaxial compound helicopter

Aerodynamic interference and unsteady loads for a trimming intermeshing rotor compound propeller helicopter at level forward flight

A New Algorithm on Automatic Trimming for Helicopter Rotor Aerodynamic Loads

Main helicopter rotor trimming using computational fluid dynamics method in forward flight

CFD analysis on the performance of a coaxial rotor with lift offset at high advance ratios

Comprehensive Modeling and Analysis of an Unmanned Coaxial Helicopter