Abstract:Continuous monitoring of physical motion, which can be successfully achieved via a wireless flexible wearable electronic device, is essential for people to ensure the appropriate level of exercise. Currently, most of the flexible LC pressure sensors have low sensitivity because of the high Young’s modulus of the dielectric properties (such as PDMS) and the inflexible polymer films (as the substrate of the sensors), which don’t have excellent stretchability to conform to arbitrarily curved and moving surfaces such as joints. In the LC sensing system, the metal rings, as the traditional readout device, are difficult to meet the needs of the portable readout device for the integrated and planar readout antenna. In order to improve the pressure sensitivity of the sensor, the Ecoflex microcolumn used as the dielectric of the capacitive pressure sensor was prepared by using a metal mold copying method. The Ecoflex elastomer substrates enhanced the levels of conformability, which offered improved capabilities to establish intimate contact with the curved and moving surfaces of the skin. The pressure was applied to the sensor by weights, and the resonance frequency curves of the sensor under different pressures were obtained by the readout device connected to the vector network analyzer. The experimental results show that resonant frequency decreases linearly with the increase of applied pressure in a range of 0–23,760 Pa with a high sensitivity of −2.2 MHz/KPa. We designed a coplanar waveguide-fed monopole antenna used to read the information of the LC sensor, which has the potential to be integrated with RF signal processing circuits as a portable readout device and a higher vertical readout distance (up to 4 cm) than the copper ring. The flexible LC pressure sensor can be attached to the skin conformally and is sensitive to limb bending and facial muscle movements. Therefore, it has the potential to be integrated as a body sensor network that can be used to monitor physical motion.

Toward Flexible Wireless Pressure‐Sensing Device Via Ionic Hydrogel Microsphere for Continuously Mapping Human‐Skin Signals

Flexible capacitive pressure sensor array using acoustic-assisted fabrication of microstructures as surface and dielectric layers

Flexible Wireless Passive LC Pressure Sensor with Design Methodology and Cost-Effective Preparation

High-Sensitivity Flexible Capacitive Pressure Sensors Based on Biomimetic Hibiscus Flower Microstructures

Flexible Capacitive Pressure Sensor Based on an Embedded Rib Fabric With a Bionic Sloping Petal Structure

Multifunctional skin-compliant wearable sensors for monitoring human condition applications

Highly Sensitive and Flexible Capacitive Pressure Sensor Based on a Dual-Structured Nanofiber Membrane as the Dielectric for Attachable Wearable Electronics

One-Step Process of Wrinkle Microstructured Iontronic Pressure Sensor with All Fabric Wearable Electrode

Silver nanowires/waterborne polyurethane composite film based piezoresistive pressure sensor for ultrasensitive human motion monitoring

Skin-Inspired Textile Electronics Enable Ultrasensitive Pressure Sensing

All-Nanofibrous Ionic Capacitive Pressure Sensor for Wearable Applications

A Flexible and Ultra-Highly Sensitive Tactile Sensor through a Parallel Circuit by a Magnetic Aligned Conductive Composite

Extremely stretchable and healable ionic conductive hydrogels fabricated by surface competitive coordination for human-motion detection

A Flexible Piezocapacitive Pressure Sensor with Microsphere-Array Electrodes

Wearable ion gel based pressure sensor with high sensitivity and ultra-wide sensing range for human motion detection

High-efficient flexible pressure sensor based on nanofibers and carbon nanotubes for artificial electronic skin and human motion monitoring

Flexible capacitive pressure sensors with micro-patterned porous dielectric layer for wearable electronics

A Flexible Pressure Sensor Based on Silicon Nanomembrane

Flexible Pseudocapacitive Iontronic Tactile Sensor Based on Microsphere‐Decorated Electrode and Microporous Polymer Electrolyte for Ultrasensitive Pressure Detection

Highly sensitive and flexible wearable pressure sensor with dielectric elastomer and carbon nanotube electrodes

Rationally Designed Cellulose Hydrogel for Ultrasensitive Pressure Sensor