Abstract:With the continuous upgrading of hypersonic vehicles, a new design requirement for imaging window is put forward, that is, conformal window to improve aerodynamic characteristics, which requires the supersonic cooling film and optical window to maintain the same curvature shape as the aircraft body.This paper investigates the mixed-layer flow evolution on a convex wall (CV). The flow field structure of the mixed layer is captured using a nanoparticle-based planar laser scattering technique in a Ma =6 hypersonic static wind tunnel, combined with fractal dimension to investigate the location of mixed-layer instability. Results of pressure, and impulse of compression ( Ip ) evolution along the flow direction were obtained using numerical simulation techniques. The results show that the total incoming pressure ( P 0 ) has a significant effect on the flow evolution of the mixed layer, and as P 0 increases, the ratio of static pressure (RSP) decreases, the position of the mixed layer instability is delayed, and the flow velocity of the typical vortex structure increases. The presence of favorable gradients at the CV wall allows the pressure to drop along the flow direction, and the pressure is boosted when the supersonic air film along the tangential direction of the wall is in operating condition. However, as P 0 increases, RSP decreases with it, and the lifting effect of the pressure on the CV decreases. The flow field is affected by the expansion effect of the CV, and Ip decreases along the flow direction. The supersonic air film can weaken the expansion effect on the CV and thus suppress the decrease of Ip . The change rate of Ip ( ΔIp ) is significantly affected by P 0 , in the range of bending impulse | I Φ |=0.191~3.62, ΔIp decreases from 178.67% to 12.02% when P 0 =0.5Mpa and ΔIp decreases from 40.38% to 5.64% when P 0 =1.0MPa. ΔIp decreases as | I Φ | increases, but the decrease weakens as P 0 increases. The results reveal the flow evolution law of hypersonic mixed layer under the influence of convex curvature, and provide a certain reference for the shape design of hypersonic vehicle to achieve aerodynamic drag reduction and thermal protection characteristics.

Modeling Spatial Evolution of Aero-Optical Wave Front Aberration Caused by a Supersonic Mixing Layer

The Wavefront Aberration Analysis and Testing Accuracy Evaluation for the Large Aberration Aspheric System Based on the Best Fit Sphere

The wavefront aberration analysis and testing accuracy evaluation for the large aberration aspheric system based on the best fit sphere - art. no. 68342V

Numerical Analysis of the Micro-Couette Flow Using a Non-Newton–fourier Model with Enhanced Wall Boundary Conditions

Spatial-temporal-covariance-based modeling, analysis, and simulation of aero-optics wavefront aberrations

Modeling the temporal evolution of an aero-optical aberration with the minimum description length principle

Correcting the aero-optical aberration of the supersonic mixing layer with adaptive optics: concept validation

Aero-optical Aberration Measuring Method Based on NPLS and Its Application

Numerical Investigation of Aero-Optical Distortions from High-Speed Turbulent Boundary Layers

Experimental Investigation on Aero-Optical Aberration of the Supersonic Flow Passing Through an Optical Dome with Gas Injection?

Formation and Evolution of the Streamwise Vortices in Mixing Layers

Evolution of Three-Dimensional Temporally Evolving Plane Mixing Layers Under Strong Vortex Disturbances

Direct numerical simulation of three-dimensional spatially developing supersonic plane mixing layer

Wavelet Analysis of Coherent Structures in a Three-Dimensional Mixing Layer

Dynamic mode decomposition based predictive model performance on supersonic and transonic aero-optical wavefront measurements

Vortex Structures and Mixing of Compressible Mixing Layer

The Shock Wave Refraction in Supersonic Planar Mixing Layers

Analysis of wavefront aberration induced by turbulent flow field in liquid-convection-cooled disk laser

Experimental investigation of aero-optics induced by supersonic film based on near-field background-oriented schlieren

Study on The Flow Evolution of Mixed Layer with Convex Curvature Wall Under Hypersonic Conditions

Spectral Characterization of Optical Aberrations in Fluidic Lenses