Abstract:Inefficient conversion of structure-complicated and oxygen-enriched asphaltenes is found as the major challenge facing coal tar in achieving high value-added utilization. Hydrogenation technology is the primary way to achieve the impurity removal and lightweight of coal tar asphaltenes (CTAS). In this study, the evolution laws of functional groups and structural parameters at different reaction times, and pyrolysis behavior at different temperatures of coal tar asphaltenes (CTAS) during the hydrotreating (HDT) process were investigated using the methods of FT-IR, XPS, 1 H-NMR, 13 C-NMR and Py-GC/MS. It was found that the increase of the reaction time significantly affected CTAS hydrodeoxygenation (HDO), and most of nitrogen-containing compounds (NCs) and sulfur-containing compounds (SCs) could be removed in a shorter reaction time. However, the increase of the reaction time has a limited effect on the removal of NCs and SCs embedded in polycyclic aromatic compounds. The average alkyl chain length ( L ) decreased with the increase of the reaction time, and the degree of branching for alkyl side chains ( B ) increased after HDT. The aromatic ring substitution degree (σ) and alkyl substituents number ( n ) of CTAS increased after HDT. The OH-OH and OH-ether O were found as the major hydrogen bonds in asphaltene feed (Asp-feed) and asphaltene product (Asp-product), followed by OH-π and cyclic OH. With the increase of reaction time, the molar fraction of the OH-ether O hydrogen bonds increased, while OH-π hydrogen bonds decreased. C-O group was found as the critical oxygen-containing functional group in Asp-feed and Asp-product, primarily existing in the form of aromatic ether groups and C-O of phenols. With the increase of reaction time, the molar fraction of aromatic ether groups in CTAS increased significantly, while that of the C-O of phenols decreased. The pyrolysis fragments of Asp-feed and Asp-product were largely 1-3 ring aromatic hydrocarbons or heteroatoms compounds. Heteroatoms compounds primarily consisted of phenols and furans, whose alkyl side chains were short and few, mainly existing in the form of multiple methyl groups. The Asp-product produced smaller aromatic ring fragments, more aromatic hydrocarbons and less phenolic and non-phenolic oxygenated compounds than Asp-feed at the same pyrolysis temperatures

Pyrolysis of Asphaltenes in Subcritical and Supercritical Water: Influence of H-Donation from Hydrocarbon Surroundings

Thermal Pyrolysis Kinetics of Asphaltenes from Several Crude Oils.

Pyrolysis of Coal-Tar Asphaltene in Supercritical Water

Simplification of Pyrolytic Reaction Mechanism and Turbulent Heat Transfer of N-Decane at Supercritical Pressures

Supercritical-Pressure Heat Transfer, Pyrolytic Reactions, and Surface Coking of N-Decane in Helical Tubes

Non-isothermal Kinetics of Styrene—butadiene—styrene Asphalt Combustion

Tracing the Composition and Structure Evolution of Oxygen-enriched Asphaltenes During the Hydrotreating of Middle-low Temperature Coal Tar

Thermodynamic Analysis of Asphaltene Pyrolysis in Thermal Plasma Reactor

Investigation of the Composition and Laminar Flame Speed of Pyrolysis Gases

Effects Of Hydrogen Donor And Hydrogen On Thermal-, Hydro-, And Catalytic Hydro-Cracking Of Subfractions Of Liaohe Residue.

Sorption of Organic Compounds by Pyrolyzed Humic Acids

The mechanism of superheated steam affecting the quality of in-situ pyrolysates of oil shale kerogen: Part A-saturation of pyrolytic organics

Pyrolysis characteristics and evolution of the organics in Nong'an oil shale lump during sub-critical water extraction

Insight into asphaltene transformation during coal tar hydrotreatment by conventional analysis and high-resolution Fourier transform mass spectrometry coupled with collision-induced dissociation technology

Thermogravimetric analysis of petroleum asphaltenes along with estimation of average chemical structure by nuclear magnetic resonance spectroscopy

Effect of Hydrogen Donor and Precursor of Donor on Catalytic Hydro-Cracking Reaction of Residue Oil

Particle-scale Modeling of Asphaltene Pyrolysis in Thermal Plasma

IN SITU VISUALIZATION OF PYROLYSIS OF ORGANIC MATTER IN HIGH-TEMPERATURE AND HIGH-PRESSURE WATER——TAKING KEROGEN AND ASPHALT AS AN EXAMPLE

Degradation pathways and product formation mechanisms of asphaltene in supercritical water

Effects of Asphaltenes on the Formation and Decomposition of Methane Hydrate: A Molecular Dynamics Study

Pyrolysis and Coking of n-Heptane under Supercritical Conditions