Abstract:Interfacial shear stress has an important influence on the vapor downward condensation heat transfer in a smaller diameter condenser tube. At the present work, a volume of fluid (VOF) method based on the vapor-liquid interfacial capturing technique was used to numerically analyze the effects of interfacial shear stress on local condensation heat transfer coefficients (HTC) during the vapor downflow condensation. Because vapor condenses on the vapor-liquid interface, the condensation mass and energy source items were introduced into the volume fraction and energy governing equations of the VOF model. In addition, the condenser tube wall temperature was acquired by a coupling calculation of cooling water forced convection heat transfer. The parameters were obtained, including velocity, interfacial shear stress and local condensation HTC. The computations show that interfacial stress shear degrades along the tube length, obviously improving the condensation heat transfer at the condenser tube front. At the condenser tube rear, the vapor-liquid interfacial shear stress decreases, having a drag force to condensate. Therefore, the liquid-film gravity plays an important role in local condensation HTC at the condenser tube rear. Local condensation HTC obtained by the VOF method is compared with the Nusselt analytic solution. At the condenser tube front, the vapor-liquid interfacial shear stress is higher and has the same direction as condensate velocity, which enhances the condensation heat transfer by reducing the liquid film thickness. So local condensation HTC obtained by the VOF method is higher than the Nusselt analytic solution. However, at the condenser tube rear, the computing result is almost equal to the Nusselt analytic solution as a result of both lower interfacial shear stress and increasing the liquid film thickness. Furthermore, a comparison of local condensation HTC acquired by the VOF method to the experimental data of Goodykoontz et al. was performed, good agreements were found for the condenser tube section from 0.2 m to 0.6 m, and their relative error is within ±35%. © All Rights Reserved.

VACUUM CONDENSATION IN AN INCLINED FLAT TUBE: HEAT TRANSFER AND PRESSURE DROP

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Experimental Study on Condensation Heat Transfer Characteristics Inside an Inclined Wave-Finned Flat Tube of Direct Air-Cooling System

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Development of an Analytical Model for Pure Vapor Downflow Condensation in a Vertical Tube

Numerical Investigation of Condensation in Inclined Tube Air-Cooled Condensers

Numerical Study on Condensation Annular Flow of R1234ze(E) Inside an Inclined Tube

Study on laminar film-wise condensation for vapor flow in an inclined small/mini-diameter tube

Numerical study on heat transfer and pressure drop characteristics of R410A condensation in horizontal circular mini/micro tubes

Computational Fluid Dynamics Modeling of Steam Condensation in the Presence of Noncondensable Gas in Inclined Tubes

Condensation heat transfer for vapor flow in an inclined tube of small or mini diameter

Heat transfer characteristics in vertical tube condensers: Experimental investigation and numerical validation

Experimental Study on Condensation of Steam/air Mixture in a Horizontal Tube

Experimental Study on Heat Transfer Characteristics of A Condenser in the Presence of Air

Analysis of interfacial shear stress effects on vapor downward condensation heat transfer

Observation and Calculation of Stratified Flow in the Tube of an Air Cooled Condenser

Numerical Investigation of Air-Steam Condensation in a Vertically Enhanced Tube with Concave and Convex Surfaces

Experimental Investigation of Condensation in Micro-Fin Tubes of Different Geometries

Numerical Investigation on Condensation Heat Transfer and Pressure Drop Characteristics of R134a in Horizontal Flattened Tubes

Experiment and Simulation on Downward Flow Condensation of Nitrogen in Vertical Tubes

Analysis of enhanced heat transfer of film condensation on vertical fluted tubes